Airworthiness Directives: Cessna Aircraft Company, Models 208 and 208B Airplanes,
[Federal Register: March 17, 2008 (Volume 73, Number 52)]
[Proposed Rules]
[Page 14191-14193]
From the Federal Register Online via GPO Access [wais.access.gpo.gov]
[DOCID:fr17mr08-13]
DEPARTMENT OF TRANSPORTATION
Federal Aviation Administration
[Docket No. FAA-2008-0331; Directorate Identifier 2008-CE-009-AD]
RIN 2120-AA64
Airworthiness Directives; Cessna Aircraft Company, Models 208 and 208B Airplanes
AGENCY: Federal Aviation Administration (FAA), Department of Transportation (DOT).
ACTION: Notice of proposed rulemaking (NPRM).
SUMMARY: We propose to adopt a new airworthiness directive (AD) for certain Cessna Aircraft Company (Cessna) Models 208 and 208B airplanes. This proposed AD would require inspection of the left and right wing wire bundle(s) and repair or replacement of damaged wire. This proposed AD would also require inspecting the wire bundles for correct attachment to the anchor points and correcting any deficient attachments. This proposed AD results from chafed wiring found on wire bundles in the left and right wings containing the auto-control wing de-ice system, fuel quantity indication, and low fuel annunciation on the Cessna 208B airplanes. Improper installation of wire bundle supporting hardware can cause chafed wiring in the affected bundles. We are proposing this AD to detect and correct damaged wiring of the auto- control wing de-ice system, fuel quantity indication, and low fuel annunciation systems. This condition could result in incorrect fuel quantity indications, loss of low fuel quantity annunciations, or loss of the autocontrol wing de-ice system.
DATES: We must receive comments on this proposed AD by May 16, 2008.
ADDRESSES: Use one of the following addresses to comment on this proposed AD:
Federal eRulemaking Portal: Go to http:// www.regulations.gov. Follow the instructions for submitting comments.
Fax: (202) 493-2251.
Mail: U.S. Department of Transportation, Docket Operations, M-30, West Building Ground Floor, Room W12-140, 1200 New Jersey Avenue, SE., Washington, DC 20590.
Hand Delivery: U.S. Department of Transportation, Docket Operations, M-30, West Building Ground Floor, Room W12-140, 1200 New Jersey Avenue, SE., Washington, DC 20590, between 9 a.m. and 5 p.m., Monday through Friday, except Federal holidays.
For service information identified in this proposed AD, contact Cessna Aircraft Company, One Cessna Boulevard, P.O. Box 7706, Wichita, KS 67277-7704; telephone: (316) 517-5800; fax: (316) 942-9006.
FOR FURTHER INFORMATION CONTACT: Daniel Hilton, Aerospace Engineer, FAA, Wichita Aircraft Certification Office, 1801 Airport Road, Room 100, Wichita, Kansas 67209; telephone: 316-946-4173; e-mail address: daniel.hilton@faa.gov.
SUPPLEMENTARY INFORMATION:
Comments Invited
We invite you to send any written relevant data, views, or arguments regarding this proposed AD. Send your comments to an address listed under the ADDRESSES section. Include the docket number, ``FAA- 2008-0331; Directorate Identifier 2008-CE-009-AD'' at the beginning of your comments. We specifically invite comments on the overall regulatory, economic, environmental, and energy aspects of the proposed AD. We will consider all comments received by the closing date
[[Page 14192]]
and may amend the proposed AD in light of those comments.
We will post all comments we receive, without change, to http:// www.regulations.gov, including any personal information you provide. We will also post a report summarizing each substantive verbal contact we receive concerning this proposed AD.
Discussion
We have reports of chafed wiring found on wire bundles in the left and right wings containing the auto-control wing de-ice system, fuel quantity indication, and low fuel annunciation on several Cessna Model 208B airplanes. Improper installation of wire bundle supporting hardware can cause chafed wiring in the affected bundles. We are proposing this AD to detect and correct damaged wiring of the auto- control wing de-ice system, fuel quantity indication, and low fuel annunciation systems. This condition, if not corrected, could result in incorrect fuel quantity indications, loss of low fuel quantity annunciations, or loss of the auto-control wing de-ice system.
Relevant Service Information
We have reviewed Cessna Aircraft Company Service Bulletin CAB08-02, dated February 4, 2008.
The service information describes procedures for:
Inspecting the left and right wing electrical wire bundles;
Repairing and properly attaching damaged wires; and
Properly securing loosely attached wires.
FAA's Determination and Requirements of the Proposed AD
We are proposing this AD because we evaluated all information and determined the unsafe condition described previously is likely to exist or develop on other products of the same type design. This proposed AD would require the inspection of the wire harness and repair or replacement of damaged wire.
Costs of Compliance
We estimate that this proposed AD would affect 512 airplanes in the U.S. registry.
We estimate the following costs to do the proposed inspection:
Total cost per Total cost on Labor cost
Parts cost
airplane U.S. operators
1 work-hour x $80 per hour = $80............. Not Applicable.................
$80
$40,960
We estimate the following costs to do any necessary repairs or replacements that would be required based on the results of the proposed inspection. We have no way of determining the number of airplanes that may need this repair/replacement:
Total cost per Labor cost
Parts cost
airplane
1 work-hour x $80 per hour = $80......
$10
$90
Warranty credit will be given to the extent specified in Cessna Aircraft Company Service Bulletin CAB08-02, dated February 4, 2008.
Authority for This Rulemaking
Title 49 of the United States Code specifies the FAA's authority to issue rules on aviation safety. Subtitle I, Section 106, describes the authority of the FAA Administrator. Subtitle VII, Aviation Programs, describes in more detail the scope of the Agency's authority.
We are issuing this rulemaking under the authority described in Subtitle VII, Part A, Subpart III, Section 44701, ``General requirements.'' Under that section, Congress charges the FAA with promoting safe flight of civil aircraft in air commerce by prescribing regulations for practices, methods, and procedures the Administrator finds necessary for safety in air commerce. This regulation is within the scope of that authority because it addresses an unsafe condition that is likely to exist or develop on products identified in this rulemaking action.
Regulatory Findings
We have determined that this proposed AD would not have federalism implications under Executive Order 13132. This proposed AD would not have a substantial direct effect on the States, on the relationship between the national Government and the States, or on the distribution of power and responsibilities among the various levels of government.
For the reasons discussed above, I certify that the proposed regulation:
1. Is not a ``significant regulatory action'' under Executive Order 12866;
2. Is not a ``significant rule'' under the DOT Regulatory Policies and Procedures (44 FR 11034, February 26, 1979); and
3. Will not have a significant economic impact, positive or negative, on a substantial number of small entities under the criteria of the Regulatory Flexibility Act.
We prepared a regulatory evaluation of the estimated costs to comply with this proposed AD and placed it in the AD docket.
Examining the AD Docket
You may examine the AD docket that contains the proposed AD, the regulatory evaluation, any comments received, and other information on the Internet at http://www.regulations.gov; or in person at the Docket Management Facility between 9 a.m. and 5 p.m., Monday through Friday, except Federal holidays. The Docket Office (telephone (800) 647-5527) is located at the street address stated in the ADDRESSES section. Comments will be available in the AD docket shortly after receipt.
List of Subjects in 14 CFR Part 39
Air transportation, Aircraft, Aviation safety, Safety.
The Proposed Amendment
Accordingly, under the authority delegated to me by the Administrator, the FAA proposes to amend 14 CFR part 39 as follows:
PART 39--AIRWORTHINESS DIRECTIVES
1. The authority citation for part 39 continues to read as follows:
Authority: 49 U.S.C. 106(g), 40113, 44701.
Sec. 39.13 [Amended]
2. The FAA amends Sec. 39.13 by adding the following new AD:
[[Page 14193]]
Cessna Aircraft Company: Docket No. FAA-2008-0331; Directorate Identifier 2008-CE-009-AD.
Comments Due Date
(a) We must receive comments on this airworthiness directive (AD) action by May 16, 2008.
Affected ADs
(b) None.
Applicability
(c) This AD applies to the following airplane models and serial numbers that are certificated in any category:
Models
Serial Nos.
208.............................. 20800001 through 20800415. 208B............................. 208B0001 through 208B1299.
Unsafe Condition
(d) This AD results from reports of chafed wiring found on wire bundles in the left and right wings containing the auto-control wing de-ice system, fuel quantity indication, and low fuel annunciation on several Cessna Model 208B airplanes. We are proposing this AD to detect and correct damaged wiring of the auto-control wing de-ice system, fuel quantity indication, and low fuel annunciation systems. This condition, if not corrected, could result in incorrect fuel quantity indications, loss of low fuel quantity annunciations, or loss of the auto-control wing de-ice system.
Compliance
(e) To address this problem, you must do the following, unless already done:
Actions
Compliance
Procedures
(1) Inspect the left and Within the next 200 Follow Cessna right wing electrical wire hours time-in-
Aircraft Company bundles at the anchor
service after the Service Bulletin attach points for loose and effective date of CAB08-02, dated damaged wiring.
this AD, or within February 4, 2008. 12 months after the effective date of this AD, whichever comes first. (2) If, as a result of the Before further
Follow Cessna inspection required by
flight after the Aircraft Company paragraph (e)(1) of this inspection required Service Bulletin AD, damaged wires are
by paragraph (e)(1) CAB08-02, dated found, repair or replace of this AD.
February 4, 2008. damaged wires and properly attach wire bundle. (3) If, as a result of the Before further
Follow Cessna inspection required by
flight after the Aircraft Company paragraph (e)(1) of this inspection required Service Bulletin AD, loosely attached wires by paragraph (e)(1) CAB08-02, dated were found, secure any
of this AD.
February 4, 2008. wires that are loosely attached and properly attach wire bundle supporting hardware.
Alternative Methods of Compliance (AMOCs)
(f) The Manager, Wichita Aircraft Certification Office, FAA, has the authority to approve AMOCs for this AD, if requested using the procedures found in 14 CFR 39.19. Send information to ATTN: Daniel Hilton, Aerospace Engineer, FAA, Wichita ACO, 1801 Airport Road, Room 100, Wichita, Kansas 67209; telephone: 316-946-4173; e-mail address: daniel.hilton@faa.gov. Before using any approved AMOC on any airplane to which the AMOC applies, notify your appropriate principal inspector (PI) in the FAA Flight Standards District Office (FSDO), or lacking a PI, your local FSDO.
Related Information
(g) To get copies of the service information referenced in this AD, contact Cessna Aircraft Company, One Cessna Boulevard, P.O. Box 7706, Wichita, KS 67277-7704; telephone: (316) 517-5800; fax: (316) 942-9006. To view the AD docket, go to U.S. Department of Transportation, Docket Operations, M-30, West Building Ground Floor, Room W12-140, 1200 New Jersey Avenue, SE., Washington, DC 20590, or on the Internet at http://www.regulations.gov.
Issued in Kansas City, Missouri, on March 11, 2008. David R. Showers, Acting Manager, Small Airplane Directorate, Aircraft Certification Service. [FR Doc. E8-5269 Filed 3-14-08; 8:45 am]
BILLING CODE 4910-13-P
