Airworthiness Directives:

Federal Register Volume 76, Number 164 (Wednesday, August 24, 2011)

Proposed Rules

Pages 52899-52901

From the Federal Register Online via the Government Printing Office [www.gpo.gov]

FR Doc No: 2011-21667

DEPARTMENT OF TRANSPORTATION

Federal Aviation Administration 14 CFR Part 39

Docket No. FAA-2011-0725; Directorate Identifier 2011-NM-065-AD

RIN 2120-AA64

Airworthiness Directives; The Boeing Company Model 767-200, -300, and -300F Series Airplanes

AGENCY: Federal Aviation Administration (FAA), DOT.

ACTION: Notice of proposed rulemaking (NPRM).

SUMMARY: We propose to adopt a new airworthiness directive (AD) for certain model 767-200, -300, and -300F series airplanes. This proposed

AD would require doing certain wiring changes, installing a new relay and necessary wiring in the cabin air conditioning and temperature control system (CACTCS), and performing an operational test of the cooling pack fire suppression system. This AD results from reports of loss of avionics cooling due to an unserviceable relay installed on a panel as part of the CACTCS. We are proposing this AD to prevent loss of electrical equipment bay cooling and the overheating of flight deck instruments, which would result in the eventual loss of primary flight displays, an unusually high pilot workload, and depressurization of the cabin.

DATES: We must receive comments on this proposed AD by October 11, 2011.

ADDRESSES: You may send comments by any of the following methods:

Federal eRulemaking Portal: Go to http://www.regulations.gov. Follow the instructions for submitting comments.

Fax: 202-493-2251.

Mail: U.S. Department of Transportation, Docket

Operations, M-30, West Building Ground Floor, Room W12-140, 1200 New

Jersey Avenue, SE., Washington, DC 20590.

Hand Delivery: Deliver to Mail address above between 9 a.m. and 5 p.m., Monday through Friday, except Federal holidays.

For service information identified in this proposed AD, contact

Boeing Commercial Airplanes, Attention: Data & Services Management,

P.O. Box 3707, MC 2H-65, Seattle, Washington 98124-2207; telephone 206- 544-5000, extension 1; fax 206-766-5680; e-mail me.boecom@boeing.com;

Internet https://www.myboeingfleet.com. You may review copies of the referenced service information at the FAA, Transport Airplane

Directorate, 1601 Lind Avenue, SW., Renton, Washington. For information on the availability of this material at the FAA, call 425-227-1221.

Examining the AD Docket

You may examine the AD docket on the Internet at http://www.regulations.gov; or in person at the Docket Management Facility between 9 a.m. and 5 p.m., Monday through Friday, except Federal holidays. The AD docket contains this proposed AD, the regulatory evaluation, any comments received, and other information. The street address for the Docket Office (phone: 800-647-5527) is in the ADDRESSES section. Comments will be available in the AD docket shortly after receipt.

FOR FURTHER INFORMATION CONTACT: Ana Martinez Hueto, Aerospace

Engineer, Cabin Safety and Environmental Systems Branch, ANM-150S, FAA,

Seattle Aircraft Certification Office, 1601 Lind Avenue, SW., Renton,

WA 98057-3356; phone: 425-917-6592; fax: 425-917-6590; e-mail: ana.m.hueto@faa.gov.

SUPPLEMENTARY INFORMATION:

Comments Invited

We invite you to send any written relevant data, views, or arguments about this proposal. Send your comments to an address listed under the ADDRESSES section. Include ``Docket No. FAA-2011-0725;

Directorate Identifier 2011-NM-065-AD'' at the beginning of your comments. We specifically invite comments on the overall regulatory, economic, environmental, and energy aspects of this proposed AD. We will consider all comments received by the closing date and may amend this proposed AD because of those comments.

We will post all comments we receive, without change, to http://www.regulations.gov, including any personal information you provide. We will also post a report summarizing each substantive verbal contact we receive about this proposed AD.

Discussion

We received reports of loss of avionics cooling due to an unserviceable relay. This relay was one of six relays installed on a panel as part of the CACTCS. The failure of this relay caused a smoke mode solenoid to energize, causing the air conditioning system to go into a Class E fire suppression mode, the right side of the relay pack to turn off, and the left-side relay pack to go into low-flow mode.

Over time, this caused insufficient equipment cooling and the slow depressurization of the cabin. This condition, if not corrected, could result in loss of electrical equipment bay cooling and the overheating of flight deck instruments, which would result in the eventual loss of all primary flight displays, an unusually high pilot workload, and depressurization of the cabin.

Relevant Service Information

We reviewed Boeing Special Attention Service Bulletins 767-21-0246, dated January 7, 2011 (for Model 767-200 and 767-300 series airplanes); and 767-21-0234, dated August 6, 2009 (for Model 767-300F series airplanes). These service bulletins describe procedures for changing the wire bundle route and wiring, installing a new relay and applicable wiring in the CACTCS, and doing an operational test of the cooling pack fire suppression system.

Page 52900

FAA's Determination and Proposed AD Requirements

We are proposing this AD because we evaluated all the relevant information and determined the unsafe condition described previously is likely to exist or develop in other products of these same type designs. This proposed AD would require accomplishing the actions specified in the service information described previously.

Costs of Compliance

We estimate that this proposed AD affects 35 airplanes of U.S. registry. We estimate the following costs to comply with this proposed

AD:

Estimated Costs

Parts

Cost per Cost on U.S.

Action

Labor cost

cost

product

operators

Change wire bundle, install relay, and

29 work-hours x $85 per hour

$1,240

$3,705

$129,675 operational test.

= $2,465 per relay installation.

Authority for This Rulemaking

Title 49 of the United States Code specifies the FAA's authority to issue rules on aviation safety. Subtitle I, section 106, describes the authority of the FAA Administrator. Subtitle VII: Aviation Programs, describes in more detail the scope of the Agency's authority.

We are issuing this rulemaking under the authority described in subtitle VII, part A, subpart III, section 44701: ``General requirements.'' Under that section, Congress charges the FAA with promoting safe flight of civil aircraft in air commerce by prescribing regulations for practices, methods, and procedures the Administrator finds necessary for safety in air commerce. This regulation is within the scope of that authority because it addresses an unsafe condition that is likely to exist or develop on products identified in this rulemaking action.

Regulatory Findings

We determined that this proposed AD would not have federalism implications under Executive Order 13132. This proposed AD would not have a substantial direct effect on the States, on the relationship between the national Government and the States, or on the distribution of power and responsibilities among the various levels of government.

For the reasons discussed above, I certify this proposed regulation:

(1) Is not a ``significant regulatory action'' under Executive

Order 12866,

(2) Is not a ``significant rule'' under the DOT Regulatory Policies and Procedures (44 FR 11034, February 26, 1979),

(3) Will not affect intrastate aviation in Alaska, and

(4) Will not have a significant economic impact, positive or negative, on a substantial number of small entities under the criteria of the Regulatory Flexibility Act.

List of Subjects in 14 CFR Part 39

Air transportation, Aircraft, Aviation safety, Incorporation by reference, Safety.

The Proposed Amendment

Accordingly, under the authority delegated to me by the

Administrator, the FAA proposes to amend 14 CFR part 39 as follows:

PART 39--AIRWORTHINESS DIRECTIVES 1. The authority citation for part 39 continues to read as follows:

Authority: 49 U.S.C. 106(g), 40113, 44701.

Sec. 39.13 [Amended] 2. The FAA amends Sec. 39.13 by adding the following new airworthiness directive (AD):

The Boeing Company: Docket No. FAA-2011-0725; Directorate Identifier 2010-NM-065-AD.

Comments Due Date

(a) We must receive comments by October 11, 2011.

Affected ADs

(b) None.

Applicability

(c) This AD applies to The Boeing Company Model 767-200 and -300 series airplanes, certificated in any category, as identified in

Boeing Special Attention Service Bulletin 767-21-0246, dated January 7, 2011; and Model 767-300F series airplanes, certificated in any category, as identified in Boeing Special Attention Service Bulletin 767-21-0234, dated August 6, 2009.

Subject

(d) Joint Aircraft System Component (JASC)/Air Transport

Association (ATA) of America Code 21: Air conditioning.

Unsafe Condition

(e) This AD results from reports of loss of avionics cooling due to an unserviceable relay installed on a panel as part of the cabin air conditioning and temperature control system (CACTCS). We are issuing this AD to prevent loss of electrical equipment bay cooling and the overheating of flight deck instruments, which would result in the eventual loss of primary flight displays, an unusually high pilot workload, and depressurization of the cabin.

Compliance

(f) Comply with this AD within the compliance times specified, unless already done.

Installation of New Relay and Wiring Bundle

(g) Within 72 months after the effective date of this AD: Change the wire bundle route and wiring, install a new relay and applicable wiring in the CACTCS, and do an operational test, in accordance with the Accomplishment Instructions of the service information specified in paragraph (g)(1) or (g)(2) of this AD, as applicable.

(1) For Model 767-200 and 767-300 series airplanes: Use Boeing

Special Attention Service Bulletin 767-21-0246, dated January 7, 2011.

(2) For Model 767-300F series airplanes: Use Boeing Special

Attention Service Bulletin 767-21-0234, dated August 6, 2009.

Alternative Methods of Compliance (AMOCs)

(h)(1) The Manager, Seattle Aircraft Certification Office (ACO),

FAA, has the authority to approve AMOCs for this AD, if requested using the procedures found in 14 CFR 39.19. In accordance with 14

CFR 39.19, send your request to your principal inspector or local

Flight Standards District Office, as appropriate. If sending information directly to the manager of the ACO, send it to the attention of the person identified in the Related Information section of this AD. Information may be e-mailed to: 9-ANM-Seattle-ACO-AMOC-Requests@faa.gov.

(2) Before using any approved AMOC, notify your appropriate principal inspector, or lacking a principal inspector, the manager of the local flight standards district office/certificate holding district office.

Related Information

(i) For more information about this AD, contact Ana Martinez

Hueto, Aerospace Engineer, Cabin Safety and Environmental Systems

Branch, ANM-150S, FAA, Seattle Aircraft Certification Office, 1601

Lind Avenue, SW., Renton, WA 98057-3356; phone 425-917-6592; fax 425-917-6590; e-mail: ana.m.hueto@faa.gov.

Page 52901

(j) For service information identified in this AD, contact

Boeing Commercial Airplanes, Attention: Data & Services Management,

P.O. Box 3707, MC 2H-65, Seattle, Washington 98124-2207; telephone 206-544-5000, extension 1; fax 206-766-5680; e-mail me.boecom@boeing.com; Internet https://www.myboeingfleet.com. You may review copies of the referenced service information at the FAA,

Transport Airplane Directorate, 1601 Lind Avenue, SW., Renton,

Washington. For information on the availability of this material at the FAA, call 425-227-1221.

Issued in Renton, Washington, on August 12, 2011.

Ali Bahrami,

Manager, Transport Airplane Directorate, Aircraft Certification

Service.

FR Doc. 2011-21667 Filed 8-23-11; 8:45 am

BILLING CODE 4910-13-P

VLEX uses login cookies to provide you with a better browsing experience. If you click on 'Accept' or continue browsing this site we consider that you accept our cookie policy. ACCEPT