Airworthiness Directives; Turbomeca S.A. Turboshaft Engines

Federal Register, Volume 80 Issue 226 (Tuesday, November 24, 2015)

Federal Register Volume 80, Number 226 (Tuesday, November 24, 2015)

Proposed Rules

Pages 73147-73148

From the Federal Register Online via the Government Publishing Office www.gpo.gov

FR Doc No: 2015-29748

Page 73147

DEPARTMENT OF TRANSPORTATION

Federal Aviation Administration

14 CFR Part 39

Docket No. FAA-2015-4070; Directorate Identifier 2015-NE-31-AD

RIN 2120-AA64

Airworthiness Directives; Turbomeca S.A. Turboshaft Engines

AGENCY: Federal Aviation Administration (FAA), DOT.

ACTION: Notice of proposed rulemaking (NPRM).

-----------------------------------------------------------------------

SUMMARY: We propose to adopt a new airworthiness directive (AD) for certain Turbomeca S.A. Arriel 1E2 turboshaft engines. This proposed AD was prompted by reports of uncommanded in-flight shutdowns (IFSDs). This proposed AD would require removing the tachometer box on affected engines. We are proposing this AD to prevent failure of the tachometer box, which could lead to failure of the engine, IFSD, and loss of control of the helicopter.

DATES: We must receive comments on this proposed AD by January 25, 2016.

ADDRESSES: You may send comments by any of the following methods:

Federal eRulemaking Portal: Go to http://www.regulations.gov. Follow the instructions for submitting comments.

Mail: Docket Management Facility, U.S. Department of Transportation, 1200 New Jersey Avenue SE., West Building Ground Floor, Room W12-140, Washington, DC 20590-0001.

Hand Delivery: Deliver to Mail address above between 9 a.m. and 5 p.m., Monday through Friday, except Federal holidays.

Fax: 202-493-2251.

For service information identified in this proposed AD, contact Turbomeca S.A., 40220 Tarnos, France; phone: 33 (0)5 59 74 40 00; fax: 33 (0)5 59 74 45 15. You may view this service information at the FAA, Engine & Propeller Directorate, 12 New England Executive Park, Burlington, MA. For information on the availability of this material at the FAA, call 781-238-7125.

Examining the AD Docket

You may examine the AD docket on the Internet at http://www.regulations.gov by searching for and locating Docket No. FAA-2015-

4070; or in person at the Docket Operations office between 9 a.m. and 5 p.m., Monday through Friday, except Federal holidays. The AD docket contains this proposed AD, the mandatory continuing airworthiness information (MCAI), the regulatory evaluation, any comments received, and other information. The address for the Docket Office (phone: 800-

647-5527) is in the ADDRESSES section. Comments will be available in the AD docket shortly after receipt.

FOR FURTHER INFORMATION CONTACT: Philip Haberlen, Aerospace Engineer, Engine Certification Office, FAA, Engine & Propeller Directorate, 12 New England Executive Park, Burlington, MA 01803; phone: 781-238-7770; fax: 781-238-7199; email: philip.haberlen@faa.gov.

SUPPLEMENTARY INFORMATION:

Comments Invited

We invite you to send any written relevant data, views, or arguments about this proposed AD. Send your comments to an address listed under the ADDRESSES section. Include ``Docket No. FAA-2015-4070; Directorate Identifier 2015-NE-31-AD'' at the beginning of your comments. We specifically invite comments on the overall regulatory, economic, environmental, and energy aspects of this NPRM. We will consider all comments received by the closing date and may amend this NPRM based on those comments.

We will post all comments we receive, without change, to http://www.regulations.gov, including any personal information you provide. We will also post a report summarizing each substantive verbal contact with FAA personnel concerning this NPRM.

Discussion

The European Aviation Safety Agency (EASA), which is the Technical Agent for the Member States of the European Community, has issued EASA AD 2015-0175, dated August 24, 2015 (referred to hereinafter as ``the MCAI''), to correct an unsafe condition for the specified products. The MCAI states:

There have been reports of Arriel 1E2 engines having experienced an uncommanded in-flight shut-down (IFSD) due to an untimely activation of the tachometer box shut-off system which was activated by the power turbine monitoring function of the tachometer box.

This condition, if not corrected, could potentially lead to further cases of IFSD, possibly resulting in a forced landing.

You may obtain further information by examining the MCAI in the AD docket on the Internet at http://www.regulations.gov by searching for and locating Docket No. FAA-2015-4070.

Related Service Information

Turbomeca S.A. has issued Mandatory Service Bulletin No. 292 77 0844, Version B, dated July 6, 2015. The service information describes procedures for removing pre-TU 369 tachometer boxes. This service information is reasonably available because the interested parties have access to it through their normal course of business or by the means identified in the ADDRESSES section of this NPRM.

FAA's Determination and Requirements of This Proposed AD

This product has been approved by the aviation authority of France, and is approved for operation in the United States. Pursuant to our bilateral agreement with the European Community, EASA has notified us of the unsafe condition described in the MCAI and service information referenced above. We are proposing this AD because we evaluated all information provided by EASA and determined the unsafe condition exists and is likely to exist or develop on other products of the same type design. This NPRM would require removing the pre-TU 369 tachometer box from the engine.

Costs of Compliance

We estimate that this proposed AD affects 200 engines installed on helicopters of U.S. registry. We also estimate that it would take about 3 hours per engine to comply with this proposed AD. The average labor rate is $85 per hour. Based on these figures, we estimate the cost of this proposed AD on U.S. operators to be $51,000.

Authority for This Rulemaking

Title 49 of the United States Code specifies the FAA's authority to issue

Page 73148

rules on aviation safety. Subtitle I, section 106, describes the authority of the FAA Administrator. ``Subtitle VII: Aviation Programs,'' describes in more detail the scope of the Agency's authority.

We are issuing this rulemaking under the authority described in ``Subtitle VII, Part A, Subpart III, Section 44701: General requirements.'' Under that section, Congress charges the FAA with promoting safe flight of civil aircraft in air commerce by prescribing regulations for practices, methods, and procedures the Administrator finds necessary for safety in air commerce. This regulation is within the scope of that authority because it addresses an unsafe condition that is likely to exist or develop on products identified in this rulemaking action.

Regulatory Findings

We determined that this proposed AD would not have federalism implications under Executive Order 13132. This proposed AD would not have a substantial direct effect on the States, on the relationship between the national Government and the States, or on the distribution of power and responsibilities among the various levels of government.

For the reasons discussed above, I certify this proposed regulation:

(1) Is not a ``significant regulatory action'' under Executive Order 12866,

(2) Is not a ``significant rule'' under the DOT Regulatory Policies and Procedures (44 FR 11034, February 26, 1979),

(3) Will not affect intrastate aviation in Alaska to the extent that it justifies making a regulatory distinction, and

(4) Will not have a significant economic impact, positive or negative, on a substantial number of small entities under the criteria of the Regulatory Flexibility Act.

List of Subjects in 14 CFR Part 39

Air transportation, Aircraft, Aviation safety, Incorporation by reference, Safety.

The Proposed Amendment

Accordingly, under the authority delegated to me by the Administrator, the FAA proposes to amend 14 CFR part 39 as follows:

PART 39--AIRWORTHINESS DIRECTIVES

0

1. The authority citation for part 39 continues to read as follows:

   Authority: 49 U.S.C. 106(g), 40113, 44701.

   Sec. 39.13 Amended

   0

2. The FAA amends Sec. 39.13 by adding the following new airworthiness directive (AD):

   Turbomeca S.A.: Docket No. FAA-2015-4070; Directorate Identifier 2015-NE-31-AD.

   (a) Comments Due Date

   We must receive comments by January 25, 2016.

   (b) Affected ADs

   None.

   (c) Applicability

   (1) This AD applies to Turbomeca S.A. Arriel 1E2 turboshaft engines with tachometer boxes with the following part number (P/N) and serial number (S/N) combinations:

   (i) P/N 9580116170--all S/Ns

   (ii) P/N 9580116260--all S/Ns

   (iii) P/N 9580116900--all S/Ns

   (iv) P/N 9580117110--all S/Ns

   (v) P/N 9580117550--all S/Ns 1499 and below with or without suffix letters and all S/Ns 1500 and above that do not contain the suffix letters EL.

   (2) This AD applies only to Turbomeca S.A. Arriel 1E2 turboshaft engines with tachometer boxes identified in paragraph (c)(1) of this AD that also have installed electrical connectors labeled as P10106, P10098, and P10108 or P11F, P13F, and P15F.

   (d) Reason

   This AD was prompted by reports of uncommanded in-flight shutdowns (IFSDs). We are issuing this AD to prevent failure of the tachometer box, which could lead to failure of the engine, IFSD, and loss of control of the helicopter.

   (e) Actions and Compliance

   Comply with this AD within the compliance times specified, unless already done.

   (1) Within 1,600 flight hours after the effective date of this AD, remove the affected tachometer box from the engine.

   (2) Reserved.

   (f) Credit for Previous Action

   You may take credit for the action required by paragraph (e) of this AD if you performed the action before the effective date of this AD in accordance with Turbomeca S.A. MSB 292 77 0844, Version A, dated March 4, 2015 or earlier version.

   (g) Alternative Methods of Compliance (AMOCs)

   The Manager, Engine Certification Office, FAA, may approve AMOCs for this AD. Use the procedures found in 14 CFR 39.19 to make your request. You may email your request to: ANE-AD-AMOC@faa.gov.

   (h) Related Information

   (1) For more information about this AD, contact Philip Haberlen, Aerospace Engineer, Engine Certification Office, FAA, Engine & Propeller Directorate, 12 New England Executive Park, Burlington, MA 01803; phone: 781-238-7770; fax: 781-238-7199; email: philip.haberlen@faa.gov.

   (2) Refer to MCAI European Aviation Safety Agency AD 2015-0175, dated August 24, 2015, which includes Mandatory Service Bulletin No. 292 77 0844, Version B, dated July 6, 2015, for related information. You may examine the MCAI in the AD docket on the Internet at http://www.regulations.gov by searching for and locating it in Docket No. FAA-2015-4070.

   (3) You may view this service information at the FAA, Engine & Propeller Directorate, 12 New England Executive Park, Burlington, MA. For information on the availability of this material at the FAA, call 781-238-7125.

   Issued in Burlington, Massachusetts, on November 12, 2015.

   Colleen M. D'Alessandro,

   Directorate Manager, Engine & Propeller Directorate, Aircraft Certification Service.

   FR Doc. 2015-29748 Filed 11-23-15; 8:45 am

   BILLING CODE 4910-13-P