Airworthiness directives: Empresa Brasileira de Aeronautica S.A.,

[Federal Register: March 23, 1999 (Volume 64, Number 55)]

[Rules and Regulations]

[Page 13892-13894]

From the Federal Register Online via GPO Access [wais.access.gpo.gov]

[DOCID:fr23mr99-7]

DEPARTMENT OF TRANSPORTATION

Federal Aviation Administration

14 CFR Part 39

[Docket No. 99-NM-33-AD; Amendment 39-11087; AD 99-05-04]

RIN 2120-AA64

Airworthiness Directives; Empresa Brasileira de Aeronautica S.A. (EMBRAER) Model EMB-145 Series Airplanes

AGENCY: Federal Aviation Administration, DOT.

ACTION: Final rule; request for comments.

SUMMARY: This document publishes in the Federal Register an amendment adopting airworthiness directive (AD) 99-05-04 that was sent previously to all known U.S. owners and operators of all EMBRAER Model EMB-145 series airplanes by individual notices.

This AD requires repetitive inspections to detect cracking or failure of the rod ends of the aileron power control actuator (PCA), and corrective actions, if necessary. This action is prompted by issuance of mandatory continuing airworthiness information by a foreign civil airworthiness authority. The actions specified by this AD are intended to detect and correct cracking or failure of the rod ends of the aileron PCA, which could result in reduced controllability of the airplane.

DATES: Effective March 29, 1999, to all persons except those persons to whom it was made immediately effective by emergency AD 99-05-04, issued February 19, 1999, which contained the requirements of this amendment.

The incorporation by reference of certain publications listed in the regulations is approved by the Director of the Federal Register as of March 29, 1999.

Comments for inclusion in the Rules Docket must be received on or before April 22, 1999.

ADDRESSES: Submit comments in triplicate to the Federal Aviation Administration (FAA), Transport Airplane Directorate, ANM-114, Attention: Rules Docket No. 99-NM-33-AD, 1601 Lind Avenue, SW., Renton, Washington 98055-4056.

The applicable service information may be obtained from Empresa Brasileira de Aeronautica S.A. (EMBRAER), P.O. Box 343--CEP 12.225, Sao Jose dos Campos--SP, Brazil. This information may be examined at the FAA, Transport Airplane Directorate, 1601 Lind Avenue, SW., Renton, Washington; or at the FAA, Small Airplane Directorate, Atlanta Aircraft Certification Office, One Crown Center, 1895 Phoenix Boulevard, suite 450, Atlanta, Georgia; or at the Office of the Federal Register, 800 North Capitol Street, NW., suite 700, Washington, DC.

FOR FURTHER INFORMATION CONTACT: Curtis Jackson, Aerospace Engineer, Airframe and Propulsion Branch, ACE-117A, FAA, Small Airplane Directorate, Atlanta Aircraft Certification Office, One Crown Center, 1895 Phoenix Boulevard, suite 450, Atlanta, Georgia 30337-2748; telephone (770) 703-6076; fax (770) 703-6097.

SUPPLEMENTARY INFORMATION: On February 19, 1999, the FAA issued emergency AD 99-05-04, which is applicable to all EMBRAER Model EMB-145 series airplanes.

The Departmento de Aviacao Civil (DAC), which is the airworthiness authority for Brazil, recently notified the FAA that an unsafe condition may exist on all EMBRAER Model EMB-145 series airplanes. The DAC advises that rod ends of the aileron power control actuator (PCA) failed on two airplanes. One rod end cracked and failed at the aileron connection point, and one at the wing connection point. Such failure of the rod ends of the aileron PCA, if not corrected, could result in reduced controllability of the airplane.

Explanation of Relevant Service Information

EMBRAER has issued Alert Service Bulletin 145-27-A054, Change 01, dated February 17, 1999, which describes procedures for repetitive detailed visual inspections to detect cracking or failure of the rod ends of the PCA at the aileron and wing connection points, and corrective actions, if necessary. The DAC classified this alert service bulletin as mandatory and issued Brazilian airworthiness directive 1999-02-01R1, dated February 18, 1999, in order to assure the continued airworthiness of these airplanes in Brazil.

FAA's Conclusions

This airplane model is manufactured in Brazil and is type certificated for operation in the United States under the provisions of Sec. 21.29 of the Federal Aviation Regulations (14 CFR 21.29) and the applicable bilateral airworthiness agreement. Pursuant to this bilateral airworthiness agreement, the DAC has kept the FAA informed of the situation described above. The FAA has examined the findings of the DAC, reviewed all available information, and determined that AD action is necessary for products of this type design that are certificated for operation in the United States.

Explanation of the Requirements of the Rule

Since the unsafe condition described is likely to exist or develop on other airplanes of the same type design registered in the United States, the FAA issued emergency AD 99-05-04 to detect and correct cracking or failure of the rod ends of the aileron PCA, which could result in reduced controllability of the airplane. The AD requires repetitive detailed visual inspections to detect cracking or failure of the rod ends of the aileron PCA, and corrective actions, if necessary. The actions are required to be accomplished in accordance with the alert service bulletin described previously.

Interim Action

This is considered to be interim action until final action is identified, at which time the FAA may consider further rulemaking.

Determination of Rule's Effective Date

Since it was found that immediate corrective action was required, notice and opportunity for prior public comment thereon were impracticable and contrary to the public interest, and good cause existed to make the AD effective immediately by individual notices issued on February 19, 1999, to all known U.S. owners and operators of all EMBRAER Model EMB-145 series airplanes. These conditions still exist, and the AD is hereby published in the Federal Register as an amendment to

[[Page 13893]]

section 39.13 of the Federal Aviation Regulations (14 CFR 39.13) to make it effective as to all persons.

Comments Invited

Although this action is in the form of a final rule that involves requirements affecting flight safety and, thus, was not preceded by notice and an opportunity for public comment, comments are invited on this rule. Interested persons are invited to comment on this rule by submitting such written data, views, or arguments as they may desire. Communications shall identify the Rules Docket number and be submitted in triplicate to the address specified under the caption ADDRESSES. All communications received on or before the closing date for comments will be considered, and this rule may be amended in light of the comments received. Factual information that supports the commenter's ideas and suggestions is extremely helpful in evaluating the effectiveness of the AD action and determining whether additional rulemaking action would be needed.

Comments are specifically invited on the overall regulatory, economic, environmental, and energy aspects of the rule that might suggest a need to modify the rule. All comments submitted will be available, both before and after the closing date for comments, in the Rules Docket for examination by interested persons. A report that summarizes each FAA-public contact concerned with the substance of this AD will be filedin the Rules Docket.

Commenters wishing the FAA to acknowledge receipt of their comments submitted in response to this rule must submit a self-addressed, stamped postcard on which the following statement is made: ``Comments to Docket Number 99-NM-33-AD.'' The postcard will be date stamped and returned to the commenter.

Regulatory Impact

The regulations adopted herein will not have substantial direct effects on the States, on the relationship between the national government and the States, or on the distribution of power and responsibilities among the various levels of government. Therefore, in accordance with Executive Order 12612, it is determined that this final rule does not have sufficient federalism implications to warrant the preparation of a Federalism Assessment.

The FAA has determined that this regulation is an emergency regulation that must be issued immediately to correct an unsafe condition in aircraft, and that it is not a ``significant regulatory action'' under Executive Order 12866. It has been determined further that this action involves an emergency regulation under DOT Regulatory Policies and Procedures (44 FR 11034, February 26, 1979). If it is determined that this emergency regulation otherwise would be significant under DOT Regulatory Policies and Procedures, a final regulatory evaluation will be prepared and placed in the Rules Docket. A copy of it, if filed, may be obtained from the Rules Docket at the location provided under the caption ADDRESSES.

List of Subjects in 14 CFR Part 39

Air transportation, Aircraft, Aviation safety, Incorporation by reference, Safety.

Adoption of the Amendment

Accordingly, pursuant to the authority delegated to me by the Administrator, the Federal Aviation Administration amends part 39 of the Federal Aviation Regulations (14 CFR part 39) as follows:

PART 39--AIRWORTHINESS DIRECTIVES

  1. The authority citation for part 39 continues to read as follows:

    Authority: 49 U.S.C. 106(g), 40113, 44701.

    Sec. 39.13 [Amended]

  2. Section 39.13 is amended by adding the following new airworthiness directive:

    99-05-04 Empresa Brasileira De Aeronautica S.A. (EMBRAER): Amendment 39-11087. Docket 99-NM-33-AD.

    Applicability: All Model EMB-145 series airplanes, certificated in any category.

    Note 1: This AD applies to each airplane identified in the preceding applicability provision, regardless of whether it has been modified, altered, or repaired in the area subject to the requirements of this AD. For airplanes that have been modified, altered, or repaired so that the performance of the requirements of this AD is affected, the owner/operator must request approval for an alternative method of compliance in accordance with paragraph (d) of this AD. The request should include an assessment of the effect of the modification, alteration, or repair on the unsafe condition addressed by this AD; and, if the unsafe condition has not been eliminated, the request should include specific proposed actions to address it.

    Compliance: Required as indicated, unless accomplished previously.

    To detect and correct cracking or failure of the rod ends of the aileron power control actuator (PCA), which could result in reduced controllability of the airplane, accomplish the following:

    Initial and Repetitive Inspections

    (a) Within 24 hours (1 day) after the effective date of this AD, perform a detailed visual inspection to detect cracking or failure of the rod ends of the PCA at the aileron and wing connection points, in accordance with EMBRAER Alert Service Bulletin 145-27- A054, Change 01, dated February 17, 1999. Repeat the inspection in accordance with the alert service bulletin thereafter at intervals not to exceed 3 days or 25 flight hours, whichever occurs later.

    Corrective Actions

    (b) If any cracked or failed rod end is detected during any inspection performed in accordance with paragraph (a) of this AD, prior to further flight, replace the aileron PCA with a new part having the same part number, in accordance with EMBRAER Alert Service Bulletin 145-27-A054, Change 01, dated February 17, 1999.

    Reporting Requirement

    (c) Within 10 days after the replacement of any aileron PCA in accordance with paragraph (b) of this AD, submit a report of the cracked or failed rod end to the Manager, Atlanta Aircraft Certification Office (ACO), FAA, Small Airplane Directorate, One Crown Center, 1895 Phoenix Boulevard, suite 450, Atlanta, Georgia 30349; fax (770) 703-6097. Information collection requirements contained in this regulation have been approved by the Office of Management and Budget (OMB) under the provisions of the Paperwork Reduction Act of 1980 (44 U.S.C. 3501 et seq.) and have been assigned OMB Control Number 2120-0056.

    Alternative Methods of Compliance

    (d) An alternative method of compliance or adjustment of the compliance time that provides an acceptable level of safety may be used if approved by the Manager, Atlanta ACO. Operators shall submit their requests through an appropriate FAA Principal Maintenance Inspector, who may add comments and then send it to the Manager, Atlanta ACO.

    Note 2: Information concerning the existence of approved alternative methods of compliance with this AD, if any, may be obtained from the Atlanta ACO.

    Special Flight Permits

    (e) Special flight permits may be issued in accordance with sections 21.197 and 21.199 of the Federal Aviation Regulations (14 CFR 21.197 and 21.199) to operate the airplane to a location where the requirements of this AD can be accomplished.

    Incorporation by Reference

    (f) Except as provided by paragraph (c) of this AD, the actions shall be done in accordance with EMBRAER Alert Service Bulletin 145- 27-A054, Change 01, dated February 17, 1999. This incorporation by reference was approved by the Director of the Federal Register in accordance with 5 U.S.C. 552(a) and 1 CFR part 51. Copies may be obtained from Empresa Brasileira de Aeronautica S.A. (EMBRAER), P.O. Box 343--CEP 12.225, Sao Jose dos Campos--SP, Brazil. Copies may be inspected at the FAA,

    [[Page 13894]]

    Transport Airplane Directorate, 1601 Lind Avenue, SW., Renton, Washington; or at the FAA, Small Airplane Directorate, Atlanta ACO, One Crown Center, 1895 Phoenix Boulevard, suite 450, Atlanta, Georgia; or at the Office of the Federal Register, 800 North Capitol Street, NW., suite 700, Washington, DC.

    Note 3: The subject of this AD is addressed in Brazilian airworthiness directive 1999-02-01R1, dated February 18, 1999.

    (g) This amendment becomes effective on March 29, 1999, to all persons except those persons to whom it was made immediately effective by emergency AD 99-05-04, issued February 19, 1999, which contained the requirements of this amendment.

    Issued in Renton, Washington, on March 16, 1999. Darrell M. Pederson, Acting Manager, Transport Airplane Directorate, Aircraft Certification Service.

    [FR Doc. 99-6981Filed3-22-99; 8:45 am]

    BILLING CODE 4910-13-U

VLEX uses login cookies to provide you with a better browsing experience. If you click on 'Accept' or continue browsing this site we consider that you accept our cookie policy. ACCEPT