Airworthiness directives: Empresa Brasileira de Aeronautica S.A. (EMBRAER),
[Federal Register: November 4, 2004 (Volume 69, Number 213)]
[Proposed Rules]
[Page 64262-64263]
From the Federal Register Online via GPO Access [wais.access.gpo.gov]
[DOCID:fr04no04-12]
[[Page 64262]]
DEPARTMENT OF TRANSPORTATION
Federal Aviation Administration
[Docket No. FAA-2004-19526; Directorate Identifier 2004-NM-140-AD]
RIN 2120-AA64
Airworthiness Directives; Empresa Brasileira de Aeronautica S.A. (EMBRAER) Model EMB-135BJ Series Airplanes
AGENCY: Federal Aviation Administration (FAA), DOT.
ACTION: Notice of proposed rulemaking (NPRM).
SUMMARY: The FAA proposes to adopt a new airworthiness directive (AD) for certain EMBRAER Model EMB-135BJ series airplanes. This proposed AD would require modifying the electrical wiring for the ``stick pusher'' system. This proposed AD is prompted by a report that the stick pushers are not being inhibited when the AP/PUSH/TRIM switches are activated, which can result in reduced controllability of the airplane if there is a system malfunction. We are proposing this AD to prevent reduced controllability of the airplane if the stick pusher system malfunctions.
DATES: We must receive comments on this proposed AD by December 6, 2004.
ADDRESSES: Use one of the following addresses to submit comments on this proposed AD.
DOT Docket Web site: Go to http://dms. dot. gov and follow
the instructions for sending your comments electronically.
Government-wide rulemaking Web site: Go to http://www.
regulations. gov and follow the instructions for sending your comments electronically.
Mail: Docket Management Facility, U.S. Department of Transportation, 400 Seventh Street, SW., Nassif Building, room PL-401, Washington, DC 20590.
By fax: (202) 493-2251.
Hand Delivery: Room PL-401 on the plaza level of the Nassif Building, 400 Seventh Street, SW., Washington, DC, between 9 a.m. and 5 p.m., Monday through Friday, except Federal holidays.
For service information identified in this proposed AD, contact Empresa Brasileira de Aeronautica S.A. (EMBRAER), P.O. Box 343--CEP 12.225, Sao Jose dos Campos--SP, Brazil.
You can examine the contents of this AD docket on the Internet at http://dms.dot.gov, or in person at the Docket Management Facility,
U.S. Department of Transportation, 400 Seventh Street, SW., room PL- 401, on the plaza level of the Nassif Building, Washington, DC.
FOR FURTHER INFORMATION CONTACT:
Technical information: Todd Thompson, Aerospace Engineer, International Branch, ANM-116, FAA, Transport Airplane Directorate, 1601 Lind Avenue, SW., Renton, Washington 98055-4056; telephone (425) 227-1175; fax (425) 227-1149.
Plain language information: Marcia Walters, marcia.walters@faa.gov.
SUPPLEMENTARY INFORMATION:
Docket Management System (DMS)
The FAA has implemented new procedures for maintaining AD dockets electronically. As of May 17, 2004, new AD actions are posted on DMS and assigned a docket number. We track each action and assign a corresponding directorate identifier. The DMS AD docket number is in the form ``Docket No. FAA-2004-99999.'' The Transport Airplane Directorate identifier is in the form ``Directorate Identifier 2004-NM- 999-AD.'' Each DMS AD docket also lists the directorate identifier (``Old Docket Number'') as a cross-reference for searching purposes.
Comments Invited
We invite you to submit any relevant written data, views, or arguments regarding this proposed AD. Send your comments to an address listed under ADDRESSES. Include ``Docket No. FAA-2004-19526; Directorate Identifier 2004-NM-140-AD'' at the beginning of your comments. We specifically invite comments on the overall regulatory, economic, environmental, and energy aspects of the proposed AD. We will consider all comments submitted by the closing date and may amend the proposed AD in light of those comments.
We will post all comments we receive, without change, to http://dms.dot.gov , including any personal information you provide. We will
also post a report summarizing each substantive verbal contact with FAA personnel concerning this proposed AD. Using the search function of our docket website, anyone can find and read the comments in any of our dockets, including the name of the individual who sent the comment (or signed the comment on behalf of an association, business, labor union, etc.). You can review the DOT's complete Privacy Act Statement in the Federal Register published on April 11, 2000 (65 FR 19477-78), or you can visit http://dms.dot.gov.
We are reviewing the writing style we currently use in regulatory documents. We are interested in your comments on whether the style of this document is clear, and your suggestions to improve the clarity of our communications that affect you. You can get more information about plain language at http://www.faa.gov/language and http://www.plainlanguage.gov.Examining the Docket
You can examine the AD docket on the Internet at http://dms.dot.gov , or in person at the Docket Management Facility office
between 9 a.m. and 5 p.m., Monday through Friday, except Federal holidays. The Docket Management Facility office (telephone (800) 647- 5227) is located on the plaza level of the Nassif Building at the DOT street address stated in the ADDRESSES section. Comments will be available in the AD docket shortly after the DMS receives them.
Discussion
The Departamento de Aviacao Civil (DAC), which is the airworthiness authority for Brazil, notified us that an unsafe condition may exist on certain EMBRAER Model EMB-135BJ series airplanes. The DAC advises that the ``stick pushers'' are not inhibited when the AP/PUSH/TRIM switches are activated. The switches are installed on the control wheels for the pilot and co-pilot. The stick pushers are part of the stall protection system and are automatically activated when an airplane approaches a stall condition. If the stick pushers cannot be inhibited, the workload for the pilot and co-pilot is increased because they have to exert additional physical force against the control wheels to control the airplane. Malfunction of the stick pusher system could result in reduced controllability of the airplane.
Relevant Service Information
EMBRAER has issued Service Bulletin 145LEG-27-0009, dated March 1, 2004. The service bulletin describes procedures for modifying the electrical wiring for the stick pusher system. Accomplishing the actions specified in the service information is intended to adequately address the unsafe condition. The DAC mandated the service information and issued Brazilian airworthiness directive 2004-04-02, dated May 6, 2004, to ensure the continued airworthiness of these airplanes in Brazil.
FAA's Determination and Requirements of the Proposed AD
This airplane model is manufactured in Brazil and is type certificated for operation in the United States under the
[[Page 64263]]
provisions of section 21.29 of the Federal Aviation Regulations (14 CFR 21.29) and the applicable bilateral airworthiness agreement. According to this bilateral airworthiness agreement, the DAC has kept the FAA informed of the situation described above. We have examined the DAC's findings, evaluated all pertinent information, and determined that we need to issue an AD for products of this type design that are certificated for operation in the United States.
Therefore, we are proposing this AD, which would require modifying the electrical wiring for the stick pusher system. The proposed AD would require you to use the service information described previously to perform these actions.
Costs of Compliance
The following table provides the estimated costs for U.S. operators to comply with this proposed AD.
Estimated Costs
Number of Average
Cost per
U.S.- Action
Work hours labor rate Parts airplane registered Fleet cost per hour
airplanes
Modification................
2
$65
$7
$137
7
$959
Regulatory Findings
We have determined that this proposed AD would not have federalism implications under Executive Order 13132. This proposed AD would not have a substantial direct effect on the States, on the relationship between the national Government and the States, or on the distribution of power and responsibilities among the various levels of government.
For the reasons discussed above, I certify that the proposed regulation:
-
Is not a ``significant regulatory action'' under Executive Order 12866;
-
Is not a ``significant rule'' under the DOT Regulatory Policies and Procedures (44 FR 11034, February 26, 1979); and
-
Will not have a significant economic impact, positive or negative, on a substantial number of small entities under the criteria of the Regulatory Flexibility Act.
We prepared a regulatory evaluation of the estimated costs to comply with this proposed AD. See the ADDRESSES section for a location to examine the regulatory evaluation.
List of Subjects in 14 CFR Part 39
Air transportation, Aircraft, Aviation safety, Safety.
The Proposed Amendment
Accordingly, under the authority delegated to me by the Administrator, the FAA proposes to amend 14 CFR part 39 as follows:
PART 39--AIRWORTHINESS DIRECTIVES
-
The authority citation for part 39 continues to read as follows:
Authority: 49 U.S.C. 106(g), 40113, 44701.
Sec. 39.13 [Amended]
-
The FAA amends Sec. 39.13 by adding the following new airworthiness directive (AD):
Empresa Brasileira de Aeronautica S.A. (EMBRAER): Docket No. FAA- 2004-19526; Directorate Identifier 2004-NM-140-AD.
Comments Due Date
(a) The Federal Aviation Administration must receive comments on this AD action by December 6, 2004.
Affected ADs
(b) None.
Applicability
(c) This AD applies to EMBRAER Model EMB-135BJ series airplanes, serial numbers 145462, 145495, 145505, 145528, 145625, 145637, and 145642; certificated in any category.
Unsafe Condition
(d) This AD was prompted by a report that the stick pushers are not being inhibited when the AP/PUSH/TRIM switches are activated, which can result in reduced controllability of the airplane if there is a system malfunction. We are issuing this AD to prevent reduced controllability of the airplane if the stick pusher system malfunctions.
Compliance
(e) You are responsible for having the actions required by this AD performed within the compliance times specified, unless the actions have already been done.
Modification of Electrical Wiring
(f) Within 400 flight hours or 180 calendar days after the effective date of this AD, whichever is first: Modify the wiring for the stick pusher system by accomplishing all of the actions specified in the Accomplishment Instructions of EMBRAER Service Bulletin 145LEG-27-0009, dated March 1, 2004.
Alternative Methods of Compliance (AMOCs)
(g) The Manager, International Branch, ANM-116, Transport Airplane Directorate, FAA, has the authority to approve AMOCs for this AD, if requested in accordance with the procedures found in 14 CFR 39.19.
Related Information
(h) Brazilian airworthiness directive 2004-04-02, dated May 6, 2004, also addresses the subject of this AD.
Issued in Renton, Washington, on October 21, 2004. Kalene C. Yanamura, Acting Manager, Transport Airplane Directorate, Aircraft Certification Service.
[FR Doc. 04-24632 Filed 11-3-04; 8:45 am]
BILLING CODE 4910-13-P
