Airworthiness directives: Eurocopter Deutschland GmbH Model EC135 Helicopters,

[Federal Register: February 1, 2008 (Volume 73, Number 22)]

[Rules and Regulations]

[Page 6008-6011]

From the Federal Register Online via GPO Access [wais.access.gpo.gov]

[DOCID:fr01fe08-2]

DEPARTMENT OF TRANSPORTATION

Federal Aviation Administration

14 CFR Part 39

[Docket No. FAA-2008-0101; Directorate Identifier 2007-SW-76-AD; Amendment 39-15357; AD 2007-26-51]

RIN 2120-AA64

Airworthiness Directives; Eurocopter Deutschland GmbH Model EC135 Helicopters

AGENCY: Federal Aviation Administration, DOT.

ACTION: Final rule; request for comments.

SUMMARY: This document publishes in the Federal Register an amendment adopting Airworthiness Directive (AD) 2007-26-51, which was sent previously to all known U.S. owners and operators of Eurocopter Deutschland GmbH (Eurocopter) Model EC135 helicopters by individual letters. This AD requires, within 5 hours time-in-service (TIS), inspecting the tail rotor control rod (control rod) and adjoining ball pivot and replacing any unairworthy parts before further flight. This amendment is prompted by a report of a fatal accident involving the failure of a control rod. The actions specified by this AD are intended to prevent failure of a control rod and subsequent loss of control of the helicopter.

[[Page 6009]]

DATES: Effective February 19, 2008, to all persons except those persons to whom it was made immediately effective by Emergency AD 2007-26-51, issued on December 14, 2007, which contained the requirements of this amendment.

Comments for inclusion in the Rules Docket must be received on or before April 1, 2008.

ADDRESSES: Use one of the following addresses to submit comments on this AD:

Federal eRulemaking Portal: Go to http://www.regulations.gov. Follow the instructions for submitting comments.

Fax: 202-493-2251.

Mail: U.S. Department of Transportation, Docket Operations, M-30, West Building Ground Floor, Room W12-140, 1200 New Jersey Avenue, SE., Washington, DC 20590.

Hand Delivery: U.S. Department of Transportation, Docket Operations, M-30, West Building Ground Floor, Room W12-140, 1200 New Jersey Avenue, SE., Washington, DC 20590, between 9 a.m. and 5 p.m., Monday through Friday, except Federal holidays.

You may get the service information identified in this AD from American Eurocopter Corporation, 2701 Forum Drive, Grand Prairie, Texas 75053-4005, telephone (972) 641-3460, fax (972) 641-3527.

Examining the Docket: You may examine the docket that contains the AD, any comments, and other information on the Internet at http://www.regulations.gov , or in person at the Docket Operations office

between 9 a.m. and 5 p.m., Monday through Friday, except Federal holidays. The Docket Operations office (telephone (800) 647-5527) is located in Room W12-140 on the ground floor of the West Building at the street address stated in the ADDRESSES section. Comments will be available in the AD docket shortly after receipt.

FOR FURTHER INFORMATION CONTACT: Chinh Vuong, Aviation Safety Engineer, FAA, Rotorcraft Directorate, Safety Management Group, Fort Worth, Texas 76193-0111, telephone (817) 222-5116, fax (817) 222-5961.

SUPPLEMENTARY INFORMATION: On December 14, 2007, the FAA issued Emergency AD 2007-26-51 for Eurocopter Model EC135 helicopters, which requires, within 5 hours TIS, inspecting the control rod and adjoining ball pivot and replacing any unairworthy parts before further flight. That action was prompted by a report of a fatal accident involving the failure of a control rod. This condition, if not corrected, could result in the failure of a control rod and subsequent loss of control of the helicopter.

The European Aviation Safety Agency (EASA), which is the Technical Agent for the Member States of the European Community, notified us that an unsafe condition may exist on Eurocopter EC135 and EC635 helicopters. EASA advises that an accident recently occurred with an EC135 helicopter in Japan. Preliminary investigation results indicate that the helicopter loss of control was due to the failure of the control rod.

Eurocopter has issued Alert Service Bulletin No. EC135-67A-017, dated December 13, 2007 (ASB), which specifies procedures for checking the attachment hardware on the control rod for a tight fit, checking the ball pivot for damage and freedom of movement, and replacing any damaged part before the next flight. EASA classified this ASB as mandatory and issued EASA AD No. 2007-0301-E, dated December 13, 2007, to ensure the continued airworthiness of these helicopters in the Federal Republic of Germany.

These helicopter models are manufactured in the Federal Republic of Germany and are type certificated for operation in the United States under the provisions of 14 CFR 21.29 and the applicable bilateral agreement. Pursuant to the applicable bilateral agreement, EASA has kept the FAA informed of the situation. The FAA has examined the findings of EASA, reviewed all available information, and determined that AD action is necessary for products of this type design that are certificated for operation in the United States.

Since the unsafe condition described is likely to exist or develop on other Eurocopter Model EC135 helicopters of the same type design, the FAA issued Emergency AD 2007-26-51 to prevent failure of a control rod and subsequent loss of control of the helicopter. The AD requires, within 5 hours TIS, inspecting the control rod and adjoining ball pivot and replacing any unairworthy parts before further flight. The short compliance time involved is required because the previously described critical unsafe condition can adversely affect the controllability of the helicopter. Therefore, within 5 hours TIS, inspecting the control rod and adjoining ball pivot and replacing any unairworthy parts before further flight are required, and this AD must be issued immediately.

Since it was found that immediate corrective action was required, notice and opportunity for prior public comment thereon were impracticable and contrary to the public interest, and good cause existed to make the AD effective immediately by individual letters issued on December 14, 2007, to all known U.S. owners and operators of Eurocopter Model EC135 helicopters. These conditions still exist, and the AD is hereby published in the Federal Register as an amendment to 14 CFR 39.13 to make it effective to all persons.

The FAA estimates that this AD will affect 163 helicopters of U.S. registry. We estimate 1 work hour to inspect the control rod and ball pivot and 3 work hours to replace a control rod or ball pivot, if necessary, at an average labor rate of $80 per work hour. Required parts will cost $400 for the control rod and $675 for the ball pivot, per helicopter. Based on these figures, we estimate the total cost impact of the AD on U.S. operators to be $32,765, assuming 15 helicopters require a control rod and ball pivot to be replaced.

Comments Invited

This AD is a final rule that involves requirements that affect flight safety and was not preceded by notice and an opportunity for public comment; however, we invite you to submit any written data, views, or arguments regarding this AD. Send your comments to an address listed under ADDRESSES. Include ``Docket No. FAA-2008-0101; Directorate Identifier 2007-SW-76-AD'' at the beginning of your comments. We specifically invite comments on the overall regulatory, economic, environmental, and energy aspects of the AD. We will consider all comments received by the closing date and may amend the AD in light of those comments.

We will post all comments we receive, without change, to http://www.regulations.gov , including any personal information you provide. We

will also post a report summarizing each substantive verbal contact with FAA personnel concerning this AD. Using the search function of our docket web site, you can find and read the comments to any of our dockets, including the name of the individual who sent the comment. You may review the DOT's complete Privacy Act Statement in the Federal Register published on April 11, 2000 (65 FR 19477-78), or you may visit http://www.regulations.gov for the Federal government privacy notice.

Regulatory Findings

We have determined that this AD will not have federalism implications under Executive Order 13132. This AD will not have a substantial direct effect on the States, on the relationship between the national Government and the States, or on the distribution of power and

[[Page 6010]]

responsibilities among the various levels of government.

For the reasons discussed above, I certify that the regulation:

1. Is not a ``significant regulatory action'' under Executive Order 12866;

2. Is not a ``significant rule'' under the DOT Regulatory Policies and Procedures (44 FR 11034, February 26, 1979); and

3. Will not have a significant economic impact, positive or negative, on a substantial number of small entities under the criteria of the Regulatory Flexibility Act.

We prepared an economic evaluation of the estimated costs to comply with this AD. See the AD docket to examine the economic evaluation.

Authority for This Rulemaking

Title 49 of the United States Code specifies the FAA's authority to issue rules on aviation safety. Subtitle I, section 106, describes the authority of the FAA Administrator. Subtitle VII, Aviation Programs, describes in more detail the scope of the Agency's authority.

We are issuing this rulemaking under the authority described in subtitle VII, part A, subpart III, section 44701, ``General requirements.'' Under that section, Congress charges the FAA with promoting safe flight of civil aircraft in air commerce by prescribing regulations for practices, methods, and procedures the Administrator finds necessary for safety in air commerce. This regulation is within the scope of that authority because it addresses an unsafe condition that is likely to exist or develop on products identified in this rulemaking action.

List of Subjects in 14 CFR Part 39

Air transportation, Aircraft, Aviation safety, Safety.

Adoption of the Amendment

0 Accordingly, pursuant to the authority delegated to me by the Administrator, the Federal Aviation Administration amends part 39 of the Federal Aviation Regulations (14 CFR part 39) as follows:

PART 39--AIRWORTHINESS DIRECTIVES

0 1. The authority citation for part 39 continues to read as follows:

Authority: 49 U.S.C. 106(g), 40113, 44701.

Sec. 39.13 [Amended]

0 2. Section 39.13 is amended by adding a new airworthiness directive to read as follows:

2007-26-51 Eurocopter Deutschland GmbH: Amendment 39-15357. Docket No. FAA-2008-0101; Directorate Identifier 2007-SW-76-AD.

Applicability

Model EC135 helicopters, serial number (S/N) 0005 up to and including S/N 0444, except S/N 0028, and with tail rotor control rod (control rod), part number L672M2005207, installed, certificated in any category.

Compliance

Required as indicated, unless accomplished previously.

To prevent the failure of a control rod and subsequent loss of control of the helicopter, do the following:

(a) Within 5 hours time-in-service (TIS), inspect the control rod, shown in item 7, Figure 1, of this AD, with the parts identified in parenthesis as follows:

(1) Pull the control rod (7) until it reaches its stop position. Inspect attachment hardware of control rod (7) for a tight fit. Manually inspect for possible relative motion between control rod (7) and yaw actuator (8).

(2) Inspect the locking plate (9) for a tight fit.

(3) Visually inspect the attachment hardware between control rod (7) and yaw actuator (8) for play or thread exposure. If play or thread exposure is found, before further flight, replace the control rod with an airworthy control rod.

(b) Inspect the ball pivot as shown in item 11, Figure 1, of this AD by removing the tail rotor drive shaft fairing and inspecting for a loose bearing or play. If a loose bearing or play is found, before further flight, replace the ball pivot with an airworthy ball pivot. BILLING CODE 4910-13-P

[[Page 6011]]

[GRAPHIC] [TIFF OMITTED] TR01FE08.000

BILLING CODE 4910-13-C

Note 1: Eurocopter Alert Service Bulletin No. EC135-67A-017, dated December 13, 2007, pertains to the subject of this AD.

(c) To request a different method of compliance or a different compliance time for this AD, follow the procedures in 14 CFR 39.19. Contact the Manager, Safety Management Group, FAA, ATTN: Chinh Vuong, Rotorcraft Directorate, Fort Worth, Texas 76193-0111, telephone (817) 222-5116, fax (817) 222-5961, for information about previously approved alternative methods of compliance.

Note 2: The subject of this AD is addressed in European Aviation Safety Agency (EASA) AD No. 2007-0301-E, dated December 13, 2007.

(d) This amendment becomes effective on February 19, 2008, to all persons except those persons to whom it was made immediately effective by Emergency AD No. 2007-26-51, issued December 14, 2007, which contained the requirements of this amendment.

Issued in Fort Worth, Texas, on January 23, 2008. Scott A. Horn, Acting Manager, Rotorcraft Directorate, Aircraft Certification Service.

[FR Doc. E8-1702 Filed 1-31-08; 8:45 am]

BILLING CODE 4910-13-P