Airworthiness Directives:

Federal Register: August 25, 2010 (Volume 75, Number 164)

Proposed Rules

Page 52292-52294

From the Federal Register Online via GPO Access [wais.access.gpo.gov]

DOCID:fr25au10-20

DEPARTMENT OF TRANSPORTATION

Federal Aviation Administration 14 CFR Part 39

Docket No. FAA-2010-0845; Directorate Identifier 2010-CE-044-AD

RIN 2120-AA64

Airworthiness Directives; Diamond Aircraft Industries GmbH Models

DA 40 and DA 40F Airplanes

AGENCY: Federal Aviation Administration (FAA), Department of

Transportation (DOT).

ACTION: Notice of proposed rulemaking (NPRM).

SUMMARY: We propose to adopt a new airworthiness directive (AD) for all

Diamond Aircraft Industries GmbH Models DA 40 and DA 40F airplanes.

This proposed AD would change the emergency open doors procedure by incorporation of a temporary revision into the FAA-approved airplane flight manual for all airplanes. This proposed AD would also require replacement of the passenger door retaining bracket with an improved design retaining bracket for certain airplanes. This proposed AD results from several reports of the rear passenger door departing the airplane in flight. We are proposing this AD to change the emergency open doors procedure and retrofit the rear passenger door retaining bracket, which if not corrected could result in the rear passenger door departing the airplane in flight.

DATES: We must receive comments on this proposed AD by October 12, 2010.

ADDRESSES: Use one of the following addresses to comment on this proposed AD:

Federal eRulemaking Portal: Go to http:// www.regulations.gov. Follow the instructions for submitting comments.

Fax: (202) 493-2251.

Mail: U.S. Department of Transportation, Docket

Operations, M-30, West Building Ground Floor, Room W12-140, 1200 New

Jersey Avenue, SE., Washington, DC 20590.

Hand Delivery: U.S. Department of Transportation, Docket

Operations, M-30, West Building Ground Floor, Room W12-140, 1200 New

Jersey Avenue, SE., Washington, DC 20590, between 9 a.m. and 5 p.m.,

Monday through Friday, except Federal holidays.

For service information identified in this proposed AD, contact

Diamond Aircraft Industries GmbH, N.A. Otto-Stra[szlig]e 5, A-2700

Wiener Neustadt, Austria, telephone: +43 2622 26700; fax: +43 2622 26780; e-mail: office@diamond-air.at; Internet: http://www.diamond- air.at.

FOR FURTHER INFORMATION CONTACT: Mike Kiesov, Aerospace Engineer, FAA,

Small Airplane Directorate, 901 Locust, Room 301, Kansas City, Missouri 64106; telephone: (816) 329-4144; fax: (816) 329-4090; e-mail: mike.kiesov@faa.gov.

SUPPLEMENTARY INFORMATION:

Comments Invited

We invite you to send any written relevant data, views, or arguments regarding this proposed AD. Send your comments to an address listed under the ADDRESSES section. Include the docket number, ``FAA- 2010-0845; Directorate Identifier 2010-CE-044-AD'' at the beginning of your comments. We specifically invite comments on the overall regulatory, economic, environmental, and energy aspects of the proposed

AD. We will consider all comments received by the closing date and may amend the proposed AD in light of those comments.

We will post all comments we receive, without change, to http:// www.regulations.gov, including any personal information you provide. We will also post a report summarizing each

Page 52293

substantive verbal contact we receive concerning this proposed AD.

Discussion

We have received information from Diamond Aircraft Industries GmbH that the Models DA 40 and DA 40F airplanes have had an estimated 31 rear passenger doors depart the airplane while in flight. They also estimate an additional 18 doors have been replaced because of damage to the hinge, primarily due to wind gust conditions while the airplane is parked. Diamond Aircraft Industries GmbH conducted a structural test to determine the root cause of the door opening in flight. The test concluded that the locking mechanism provided adequate strength to react the loads in flight. They determined that the root cause was the crew not properly securing the rear passenger door prior to flight.

Models DA 40 and DA 40F airplanes do have a secondary safety latch design feature. The initial intended design function of this latch was to hold the rear passenger door in the ``near closed'' position while on the ground, protecting the door from wind gusts. However, the original retainer bracket might not hold the door in this ``near closed'' position while in flight. Diamond Aircraft Industries GmbH has designed an improved retainer bracket to prevent the passenger rear door fully opening in flight. In addition, they have revised the emergency door open procedure.

This condition, if not corrected, could result in the rear passenger door departing the airplane in flight.

Relevant Service Information

We have reviewed Diamond Aircraft Industries GmbH Mandatory Service

Bulletin NO. MSB 40-070/NO. MSB D4-079/NO. MSB F4-024, dated April 30, 2010; and Diamond Aircraft Industries GmbH Work Instruction WI-MSB 40- 070/WI-MSB D4-079/WI-MSB F4-024, dated April 30, 2010.

The service information describes procedures for replacement of the passenger door retaining bracket with an improved design retaining bracket.

FAA's Determination and Requirements of the Proposed AD

We are proposing this AD because we evaluated all information and determined the unsafe condition described previously is likely to exist or develop on other products of the same type design. This proposed AD would require a retrofit of the rear passenger door retaining bracket for certain airplanes. This proposed AD would also change the emergency open doors procedure by incorporation of a temporary revision into the

FAA-approved airplane flight manual for all airplanes.

Costs of Compliance

We estimate that this proposed AD would affect 699 airplanes in the

U.S. registry.

We estimate the following costs to do the proposed revision to the airplane flight manual:

Total cost on

Labor cost

Parts cost

Total cost

U.S. per airplane

operators

.5 work-hour x $85 per hour = $42.50.......... Not Applicable..................

$42.50

$29,707.50

We estimate the following costs to do the proposed retrofit of the passenger door retaining bracket. We estimate that this would affect 428 airplanes in the U.S. registry:

Total cost on

Labor cost

Parts cost

Total cost

U.S. per airplane

operators

2 work-hours x $85 per hour = $170.00...........................

$75.00

$245.00

$104,860.00

Authority for This Rulemaking

Title 49 of the United States Code specifies the FAA's authority to issue rules on aviation safety. Subtitle I, section 106, describes the authority of the FAA Administrator. Subtitle VII, Aviation Programs, describes in more detail the scope of the Agency's authority.

We are issuing this rulemaking under the authority described in subtitle VII, part A, subpart III, section 44701, ``General requirements.'' Under that section, Congress charges the FAA with promoting safe flight of civil aircraft in air commerce by prescribing regulations for practices, methods, and procedures the Administrator finds necessary for safety in air commerce. This regulation is within the scope of that authority because it addresses an unsafe condition that is likely to exist or develop on products identified in this rulemaking action.

Regulatory Findings

We have determined that this proposed AD would not have federalism implications under Executive Order 13132. This proposed AD would not have a substantial direct effect on the States, on the relationship between the national Government and the States, or on the distribution of power and responsibilities among the various levels of government.

For the reasons discussed above, I certify that the proposed regulation: 1. Is not a ``significant regulatory action'' under Executive Order 12866; 2. Is not a ``significant rule'' under the DOT Regulatory Policies and Procedures (44 FR 11034, February 26, 1979); and 3. Will not have a significant economic impact, positive or negative, on a substantial number of small entities under the criteria of the Regulatory Flexibility Act.

We prepared a regulatory evaluation of the estimated costs to comply with this proposed AD and placed it in the AD docket.

Examining the AD Docket

You may examine the AD docket that contains the proposed AD, the regulatory evaluation, any comments received, and other information on the Internet at http://www.regulations.gov; or in person at the Docket

Management Facility between 9 a.m. and 5 p.m., Monday through Friday, except Federal holidays. The Docket Office (telephone (800) 647-5527) is located at the street address stated in the ADDRESSES section.

Comments will be available in the AD docket shortly after receipt.

Page 52294

List of Subjects in 14 CFR Part 39

Air transportation, Aircraft, Aviation safety, Incorporation by reference, Safety.

The Proposed Amendment

Accordingly, under the authority delegated to me by the

Administrator, the FAA proposes to amend 14 CFR part 39 as follows:

PART 39--AIRWORTHINESS DIRECTIVES 1. The authority citation for part 39 continues to read as follows:

Authority: 49 U.S.C. 106(g), 40113, 44701.

Sec. 39.13 [Amended] 2. The FAA amends Sec. 39.13 by adding the following new AD:

Diamond Aircraft Industries GmbH: Docket No. FAA-2010-0845;

Directorate Identifier 2010-CE-044-AD.

Comments Due Date

(a) We must receive comments on this airworthiness directive

(AD) action by October 12, 2010.

Affected ADs

(b) None.

Applicability

(c) This AD applies to Diamond Aircraft Industries GmbH Models

DA 40 and DA 40F airplanes, all serial numbers (S/N), that are certificated in any category.

Subject

(d) Air Transport Association of America (ATA) Code 52: Doors.

Unsafe Condition

(e) This AD results from several reports of the rear passenger door departing the airplane in flight. We are proposing this AD to change the emergency open doors procedure and retrofit the rear passenger door retaining bracket, which if not corrected could result in the rear passenger door departing the airplane in flight.

Compliance

(f) To address this problem, you must do the following, unless already done:

Actions

Compliance

Procedures

(1) For all serial numbers: Within 6 months

Follow Diamond

Incorporate Diamond

after the effective Aircraft Temporary

Aircraft Temporary Revision date of this AD.

Revision TR-

TR-M[Auml]M 40-428, page 3-

M[Auml]M 40-428, 37b, dated April 30, 2010,

Cover Page, dated into the FAA-approved

April 30, 2010. airplane flight manual.

(2) For Model DA 40, S/N

Within 6 months

Follow Diamond 40.006 through 40.009,

after the effective Aircraft Industries 40.011 through 40.081,

date of this AD.

GmbH Mandatory 40.084, and 40.201 through

Service Bulletin 40.749; and Model DA 40F S/

NO. MSB 40-070/NO.

N 40.FC001 through

MSB D4-079/NO. MSB 40.FC009: Replace the rear

F4-024, dated April passenger door retaining

30, 2010; and bracket with an improved

Diamond Aircraft design retaining bracket.

Industries GmbH

Work Instruction WI-

MSB 40-070/WI-MSB

D4-079/WI-MSB F4- 024, dated April 30, 2010.

Alternative Methods of Compliance (AMOCs)

(g) The Manager, Small Airplane Directorate, FAA, has the authority to approve AMOCs for this AD, if requested using the procedures found in 14 CFR 39.19. Send information to ATTN: Mike

Kiesov, Aerospace Engineer, FAA, Small Airplane Directorate, 901

Locust, Room 301, Kansas City, Missouri 64106; telephone: (816) 329- 4144; fax: (816) 329-4090; e-mail: mike.kiesov@faa.gov. Before using any approved AMOC on any airplane to which the AMOC applies, notify your appropriate principal inspector (PI) in the FAA Flight

Standards District Office (FSDO), or lacking a PI, your local FSDO.

Related Information

(h) To get copies of the service information referenced in this

AD, contact Diamond Aircraft Industries GmbH, N.A. Otto-Stra[szlig]e 5, A-2700 Wiener Neustadt, Austria, telephone: +43 2622 26700; fax:

+43 2622 26780; e-mail: office@diamond-air.at; Internet: http:// www.diamond-air.at. To view the AD docket, go to U.S. Department of

Transportation, Docket Operations, M-30, West Building Ground Floor,

Room W12-140, 1200 New Jersey Avenue, SE., Washington, DC 20590, or on the Internet at http://www.regulations.gov.

Issued in Kansas City, Missouri, on August 18, 2010.

John R. Colomy,

Acting Manager, Small Airplane Directorate, Aircraft Certification

Service.

FR Doc. 2010-21068 Filed 8-24-10; 8:45 am

BILLING CODE 4910-13-P