Airworthiness Directives:
Federal Register: October 5, 2010 (Volume 75, Number 192)
Rules and Regulations
Page 61345-61348
From the Federal Register Online via GPO Access [wais.access.gpo.gov]
DOCID:fr05oc10-6
Page 61345
DEPARTMENT OF TRANSPORTATION
Federal Aviation Administration 14 CFR Part 39
Docket No. FAA-2010-0691; Directorate Identifier 2010-CE-027-AD;
Amendment 39-16459; AD 2010-20-24
RIN 2120-AA64
Airworthiness Directives; Eclipse Aerospace, Inc. Model EA500
Airplanes
AGENCY: Federal Aviation Administration (FAA), DOT.
ACTION: Final rule.
SUMMARY: We are adopting a new airworthiness directive (AD) for the products listed above. This AD requires incorporating changes to the electronic flight information system and the airplane flight manuals.
This AD was prompted by reports of uncommanded changes to the communications radio frequency, altitude preselect, and/or transponder codes. We are issuing this AD to correct faulty integration of hardware and software, which could result in unannunciated, uncommanded changes in communications radio frequency, transponder codes, and altitude preselect settings. These uncommanded changes could result in loss of communication with air traffic control due to improper communications frequency, autopilot level off at the incorrect altitude, or air traffic control loss of proper tracking of the aircraft.
DATES: This AD is effective November 9, 2010.
The Director of the Federal Register approved the incorporation by reference of certain publications listed in the AD as of November 9, 2010.
ADDRESSES: For service information identified in this AD, contact
Eclipse Aerospace Incorporated, 2503 Clark Carr Loop, SE., Albuquerque,
New Mexico 87106; telephone: (505) 724-1200; http:// www.eclipseaerospace.net. You may review copies of the referenced service information at the FAA, Small Airplane Directorate, 901 Locust,
Kansas City, Missouri 64106. For information on the availability of this material at the FAA, call 816-329-4148.
Examining the AD Docket
You may examine the AD docket on the Internet at http:// www.regulations.gov; or in person at the Docket Management Facility between 9 a.m. and 5 p.m., Monday through Friday, except Federal holidays. The AD docket contains this AD, the regulatory evaluation, any comments received, and other information. The address for the
Docket Office (phone: 800-647-5527) is Document Management Facility,
U.S. Department of Transportation, Docket Operations, M-30, West
Building Ground Floor, Room W12-140, 1200 New Jersey Avenue, SE.,
Washington, DC 20590.
FOR FURTHER INFORMATION CONTACT: Eric Kinney, Aerospace Engineer, Ft.
Worth Aircraft Certification Office, FAA, 2601 Meacham Blvd., Fort
Worth, Texas 76137; telephone: (817) 222-5459; fax: (817) 222-5960; e- mail: eric.kinney@faa.gov.
SUPPLEMENTARY INFORMATION:
Discussion
We issued a notice of proposed rulemaking (NPRM) to amend 14 CFR part 39 to include an airworthiness directive (AD) that would apply to the specified products. That NPRM published in the Federal Register on
July 9, 2010 (75 FR 39472). That NPRM proposed to require incorporating changes to the electronic flight information system and the airplane flight manual.
Comments
We gave the public the opportunity to participate in developing this AD. The following presents the comments received on the proposal and the FAA's response to each comment.
Request To Withdraw the NPRM and Issue a Special Airworthiness
Information Bulletin (SAIB)
Chris Jackman, Eclipse Aerospace Incorporated, proposed the withdrawal of the NPRM and requested the FAA to issue an SAIB instead.
The commenter reasoned that the majority of the affected airplanes have already incorporated the corrective action, and the owners/ operators only need to send confirmation of their taking corrective action. The commenter also states that an SAIB would be the most effective means for operators to become aware of the unsafe condition and means to communicate compliance with the service information.
The FAA disagrees with the comment. The Airworthiness Directives
Manual, FAA-IR-M-8040.1C, dated May 17, 2010, prohibits the FAA from accepting assurance from a design approval holder that all products are in compliance as a reason not to issue an AD action. Consequently, we are making no change to the final rule AD action.
Request To Correct the Applicability Section
Chris Jackman requested a correction to the Applicability section, paragraph (c)(2) of the proposed AD action. He explained that the applicability in the NPRM is incorrect and should read as follows:
SNs 000039 through 000104, 000113 through 000115, 000120, and 000123 through 000124, that incorporate Avionics Upgrade to AVIO NG
Configuration for ETT Configured Aircraft per any revision level of
Eclipse SB 500-99-002.
The FAA agrees with the commenter's correction. This error was corrected in the NPRM; correction, published in the Federal Register on
August 2, 2010 (75 FR 45075). The final rule AD action incorporates that correction.
Request To Add a Reference to Eclipse Aviation Recommended Service
Bulletin SB 500-99-005, REV B, dated January 22, 2010
Chris Jackman commented that Eclipse Aviation Recommended Service
Bulletin SB 500-99-005, REV B, dated January 22, 2010, also includes procedures for compliance with this AD and requested adding a reference to that service bulletin in addition to Eclipse Aviation Recommended
Service Bulletin SB 500-99-005, REV A, dated February 16, 2009.
The FAA agrees with the commenter. We are adding a reference to
Eclipse Aviation Recommended Service Bulletin SB 500-99-005, REV B, dated January 22, 2010, to the final rule AD action.
Request To Change the Contact Information for Eclipse Aerospace
Incorporated
Chris Jackman stated the contact for service information has changed. The current name is Eclipse Aerospace Incorporated instead of
Eclipse Aviation Corporation.
The FAA agrees with the commenter. We changed the contact information in the final rule AD action.
Request To Withdraw the Proposed AD
Gerard Wasselle stated that he and at least six other owners/pilots who have vast experience in the Eclipse Model EA500 airplane, all agree that the unsafe condition presented in the proposed AD occurs only in the AVIO NG version 1.1. We infer that the commenter would like to have the proposed AD withdrawn.
We disagree with the commenter. The root cause investigation by
Eclipse Aerospace Incorporated discovered that this problem can and has occurred in Innovative Solution & Support
Page 61346
equipment with software versions 1.0 through 1.2. This AD is not applicable to Avidyne AVIO-equipped Model EA500 airplanes. We are not changing the final rule AD action as a result of this comment.
Request To Withdraw the Proposed AD Because of Cost
Gerard Wasselle stated the corrective action is cost prohibitive for owners of an older version of AVIO to upgrade to AVIO NG since it is more than the value of the airplane. We infer that the commenter would like to see the proposed AD withdrawn.
The FAA disagrees with the commenter. This AD action does not apply to Avidyne AVIO-equipped Model EA500 airplanes. We are not changing the final rule AD action as a result of this comment.
Conclusion
We reviewed the relevant data, considered the comments received, and determined that air safety and the public interest require adopting the AD with the changes described previously and minor editorial changes. We have determined that these minor changes:
Are consistent with the intent that was proposed in the
NPRM for correcting the unsafe condition; and
Do not add any additional burden upon the public than was already proposed in the NPRM.
We also determined that these changes will not increase the economic burden on any operator or increase the scope of the AD.
Costs of Compliance
We estimate that this AD affects 168 airplanes of U.S. registry.
Owners/operators will comply with this AD action by doing either of the following update options. We have no way of knowing the number of airplanes that would receive each of these upgrades.
We estimate the following costs to do the electronic flight instrument system 1.3 software update:
Total cost per
Labor cost
Parts cost
airplane
2 work-hours x $85 per hour = $600 to $1,500... $770 to $1,670.
$170.
We estimate the following costs to do the avionics upgrade to AVIO
NG + 1.5 configuration:
Total cost
Labor cost
Parts cost
per airplane
198 work-hours x $85 per hour = $16,830.......
$233,120
$249,950
Authority for This Rulemaking
Title 49 of the United States Code specifies the FAA's authority to issue rules on aviation safety. Subtitle I, section 106, describes the authority of the FAA Administrator. Subtitle VII: Aviation Programs, describes in more detail the scope of the Agency's authority.
We are issuing this rulemaking under the authority described in
Subtitle VII, Part A, Subpart III, Section 44701: ``General requirements.'' Under that section, Congress charges the FAA with promoting safe flight of civil aircraft in air commerce by prescribing regulations for practices, methods, and procedures the Administrator finds necessary for safety in air commerce. This regulation is within the scope of that authority because it addresses an unsafe condition that is likely to exist or develop on products identified in this rulemaking action.
Regulatory Findings
This AD will not have federalism implications under Executive Order 13132. This AD will not have a substantial direct effect on the States, on the relationship between the national government and the States, or on the distribution of power and responsibilities among the various levels of government.
For the reasons discussed above, I certify that this AD:
(1) Is not a ``significant regulatory action'' under Executive
Order 12866,
(2) Is not a ``significant rule'' under DOT Regulatory Policies and
Procedures (44 FR 11034, February 26, 1979),
(3) Will not affect intrastate aviation in Alaska, and
(4) Will not have a significant economic impact, positive or negative, on a substantial number of small entities under the criteria of the Regulatory Flexibility Act.
List of Subjects in 14 CFR Part 39
Air transportation, Aircraft, Aviation safety, Incorporation by reference, Safety.
Adoption of the Amendment 0
Accordingly, under the authority delegated to me by the Administrator, the FAA amends 14 CFR part 39 as follows:
PART 39--AIRWORTHINESS DIRECTIVES 0 1. The authority citation for part 39 continues to read as follows:
Authority: 49 U.S.C. 106(g), 40113, 44701.
Sec. 39.13 [Amended] 0 2. The FAA amends Sec. 39.13 by adding the following new airworthiness directive (AD): 2010-20-24 Eclipse Aerospace, Inc.: Amendment 39-16459; Docket No.
FAA-2010-0691; Directorate Identifier 2010-CE-027-AD.
Effective Date
(a) This AD is effective November 9, 2010.
Affected ADs
(b) None.
Applicability
(c) This AD applies to Model EA500 airplanes with the following serial numbers (SNs) that are certificated in any category:
(1) SNs 000105 through 000112, 000116 through 000119, 000121 through 000122, and 000125 through 000260;
(2) SNs 000039 through 000104, 000113 through 000115, 000120, and 000123 through 000124, that incorporate Avionics Upgrade to AVIO
NG Configuration for ETT Configured Aircraft per any revision level of Eclipse SB 500-99-002; and
(3) SNs 000001 through 000038, that incorporate Performance
Enhancement & Drag Reduction Modification per any revision level of
Eclipse SB 500-99-001 and Avionics Upgrade to AVIO NG Configuration for ETT Configured Aircraft per any revision level of Eclipse SB 500-99-002.
Page 61347
Subject
(d) Air Transport Association of America (ATA) Code 23:
Communications.
Unsafe Condition
(e) This AD results from reports of uncommanded changes to the communications radio frequency, altitude preselect, and/or transponder codes. We are issuing this AD to correct faulty integration of hardware and software, which could result in unannunciated, uncommanded changes in communications radio frequency, transponder codes, and altitude preselect settings. These uncommanded changes could result in loss of communication with air traffic control due to improper communications frequency, autopilot level off at the incorrect altitude, or air traffic control loss of proper tracking of the aircraft.
Compliance
(f) To address this problem, you must do the following, unless already done:
Table 1--Actions, Compliance, and Procedures
Actions (software updates and AFM revisions)
Compliance
Procedures
(1) Incorporate one of the following set of software upgrades Incorporate within the next 6 months after
Follow, as appropriate, Eclipse Aviation and AFM revisions:
November 9, 2010 (the effective date of
Required Service Bulletin SB 500[dash]31-
(i) Electronic flight instrument system (EFIS) 1.3 software
this AD).
015, REV D, dated January 14, 2009; or update and one of the following airplane flight manual
Eclipse Aviation Recommended Service revisions:
Bulletin SB 500-99-005, REV A, dated
(A) Temporary Revision (TR) 010, Airplane Flight Manual part
February 16, 2009; or Eclipse Aviation number (P/N) 06-122204 Before 3-45, Revision 01 and TR 009,
Recommended Service Bulletin SB 500-99-
Quick Reference Handbook P/N 06-122205, Revision 01; or
005, REV B, dated January 22, 2010.
(B) TR 010A, Airplane Flight Manual P/N 06-122204 Before 3- 51, Revision 02 and TR 009A, Quick Reference Handbook P/N 06- 122205, Revision 02; or
(C) Airplane Flight Manual P/N 06-122204 Revision 3, dated
February 3, 2010, and Quick Reference Handbook P/N 06- 122205, Revision 03.
(ii) Avionics upgrade to AVIO NG + 1.5 Configuration and one of the following airplane flight manual revisions:
(A) Aircraft Flight Manual, P/N 06-122204, Revision 2, dated
November 7, 2008, or
(B) AVIO NG + 1.5 configuration and Aircraft Flight Manual, P/
N 06-122204, Revision 3, dated February 10, 2010.
(2) Send the completed service bulletin compliance record
Within 30 days after you incorporate the
Not Applicable. required by paragraph (f)(1)(i) of this AD or paragraph
revisions required by paragraph (f)(1)(i)
(f)(1)(ii) of this AD to the address identified in paragraph of this AD or paragraph (f)(1)(ii) of this
(g) of this AD. The Office of Management and Budget (OMB)
AD or within 30 days after November 9, 2010 approved the information collection requirements contained
(the effective date of this AD), whichever in this regulation under the provisions of the Paperwork
occurs later.
Reduction Act of 1980 (44 U.S.C. 3501 et seq.) and assigned
OMB Control Number 2120-0056.
Alternative Methods of Compliance (AMOCs)
(g) The Manager, Fort Worth Airplane Certification Office (ACO),
FAA, has the authority to approve AMOCs for this AD, if requested using the procedures found in 14 CFR 39.19. Send information to
ATTN: Eric Kinney, Fort Worth ACO, Aerospace Engineer, 2601 Meacham
Blvd., Fort Worth, Texas 76137; telephone: (817) 222-5459; fax:
(817) 222-5960. Before using any approved AMOC on any airplane to which the AMOC applies, notify your appropriate principal inspector
(PI) in the FAA Flight Standards District Office (FSDO), or lacking a PI, your local FSDO.
Related Information
(h) For more information about this AD, contact Eric Kinney,
Aerospace Engineer, Fort Worth ACO, FAA, 2601 Meacham Blvd., Fort
Worth, Texas 76137; phone: (817) 222-5459; fax: (817) 222-5960; e- mail: eric.kinney@faa.gov.
Material Incorporated by Reference
(i) You must use the service information contained in Table 2 of this AD to do the actions required by this AD, unless the AD specifies otherwise.
(1) The Director of the Federal Register approved the incorporation by reference of the service information contained in
Table 2 of this AD under 5 U.S.C. 552(a) and 1 CFR part 51.
Table 2--Material Incorporated By Reference
Document
Revision
Date
(i) Eclipse Aviation Required
REV D............................... January 14, 2009.
Service Bulletin SB 500[dash]31-015.
(ii) Eclipse Aviation Recommended
REV B............................... January 22, 2010.
Service Bulletin SB 500-99-005.
(iii) Eclipse Aviation Recommended
REV A............................... February 16, 2009.
Service Bulletin SB 500-99-005.
(2) For service information identified in this AD, contact
Eclipse Aerospace Incorporated, 2503 Clark Carr Loop, SE.,
Albuquerque, New Mexico 87106; telephone: (505) 724-1200; http:// www.eclipseaerospace.net.
(3) You may review copies of the referenced service information at the FAA, Small Airplane Directorate, 901 Locust, Kansas City,
Missouri 64106. For information on the availability of this material at the FAA, call 816-329-4148.
(4) You may also review copies of the service information that is incorporated by
Page 61348
reference at the National Archives and Records Administration
(NARA). For information on the availability of this material at an
NARA facility, call 202-741-6030, or go to http://www.archives.gov/ federal_register/code_of_federal_regulations/ibr_ locations.html.
Issued in Kansas City, Missouri, on September 24, 2010.
Patrick R. Mullen,
Acting Manager, Small Airplane Directorate, Aircraft Certification
Service.
FR Doc. 2010-24611 Filed 10-4-10; 8:45 am
BILLING CODE 4910-13-P
