Airworthiness Directives:

Federal Register: January 5, 2011 (Volume 76, Number 3)

Rules and Regulations

Page 435-437

From the Federal Register Online via GPO Access [wais.access.gpo.gov]

DOCID:fr05ja11-8

DEPARTMENT OF TRANSPORTATION

Federal Aviation Administration 14 CFR Part 39

Docket No. FAA-2010-0797; Directorate Identifier 2010-NM-141-AD;

Amendment 39-16562; AD 2011-01-09

RIN 2120-AA64

Airworthiness Directives; B/E Aerospace Protective Breathing

Equipment (PBE) Part Number 119003-11 Installed on Various Transport

Airplanes

AGENCY: Federal Aviation Administration (FAA), DOT.

ACTION: Final rule.

SUMMARY: We are adopting a new airworthiness directive (AD) for the products listed above. This AD requires removing affected PBE units.

This AD was prompted by reports of potentially defective potassium superoxide canisters used in PBE units, which could result in an exothermic reaction and ignition. We are issuing this AD to prevent PBE units from igniting, which could result in a fire and possible injury to the flightcrew or other persons.

DATES: This AD is effective February 9, 2011.

The Director of the Federal Register approved the incorporation by reference of a certain publication listed in the AD as of February 9, 2011.

ADDRESSES: For service information identified in this AD, contact B/E

Aerospace, Inc., Commercial Aircraft Products Group, RGA Department, 10800 Pflumm Road, Lenexa, KS 66215; telephone (913) 338-7378; fax

(913) 469-8419; Internet http://www.beaerospace.com. You may review copies of the referenced service information at the FAA, Transport

Airplane Directorate, 1601 Lind Avenue, SW., Renton, Washington. For information on the availability of this material at the FAA, call 425- 227-1221.

Examining the AD Docket

You may examine the AD docket on the Internet at http:// www.regulations.gov; or in person at the Docket Management Facility between 9 a.m. and 5 p.m., Monday through Friday, except Federal holidays. The AD docket contains this AD, the regulatory evaluation, any comments received, and other information. The address for the

Docket Office (phone: 800-647-5527) is Document Management Facility,

U.S. Department of Transportation, Docket Operations, M-30, West

Building Ground Floor, Room W12-140, 1200 New Jersey Avenue, SE.,

Washington, DC 20590.

FOR FURTHER INFORMATION CONTACT: David Fairback, Aerospace Engineer,

Systems and Propulsion Branch, ACE-116W, FAA, Wichita Aircraft

Certification Office (ACO), 1801 Airport Road, Room 100, Mid-Continent

Airport, Wichita, Kansas 67209; telephone (316) 946-4154; fax (316) 946-4107; e-mail David.Fairback@faa.gov.

SUPPLEMENTARY INFORMATION:

Discussion

We issued a notice of proposed rulemaking (NPRM) to amend 14 CFR part 39 to include an airworthiness directive (AD) that would apply to the specified products. That NPRM published in the Federal Register on

August 18, 2010 (75 FR 50941). That NPRM proposed to require removing affected PBE units.

Comments

We gave the public the opportunity to participate in developing this AD. The following presents the comments received on the proposal and the FAA's response to each comment.

Support for the NPRM

Boeing supported the contents of the NPRM.

Request To Withdraw the NPRM

Continental Airlines stated that Boeing has indicated in Fleet Team

Digest 737NG-FTD-25-10003 that all defective B/E Aerospace PBEs have been successfully captured. We infer that Continental requested that we withdraw the NPRM.

We disagree with the request to withdraw the NPRM. We have not received assurance of such accomplishment. We contacted B/E Aerospace and it reported that their records show 422 of the 600 affected PBEs were contained, leaving 178 affected PBEs in the field. We have not changed the final rule in regard to this issue.

Request To Clarify Affected Serial Numbers

ABX Air requested that we clarify that no further action is required for PBEs with serial numbers outside the range. ABX Air suggested adding a new paragraph (g)(3) to the final rule to state

``For any PBE not having a serial number from 003-50730M to 003-51329M inclusive: No further action is required.''

We agree that no further action is necessary for PBEs with serial numbers outside the range specified in paragraph (g)(1) of this AD. We added a new paragraph (g)(3) to this final rule. We have also clarified paragraph (g)(2) of this AD to state that once the replacement has been done, no further action is required by paragraph (g) of this AD.

However, paragraph (h) of this AD prohibits installations of the PBEs within the serial number range.

Conclusion

We reviewed the relevant data, considered the comments received, and determined that air safety and the public interest require adopting the AD with the changes described previously. We also determined that these changes will not increase the economic burden on any operator or increase the scope of the AD.

Costs of Compliance

We estimate that this AD affects up to 600 airplanes of U.S. registry.

We estimate the following costs to comply with this AD:

Page 436

Estimated Costs

Cost per

Cost on U.S.

Action

Labor cost

Parts cost

product

operators

Inspection........................ 1 work-hour x $85 per

$0

$85

$51,000 hour = $85.

Authority for This Rulemaking

Title 49 of the United States Code specifies the FAA's authority to issue rules on aviation safety. Subtitle I, section 106, describes the authority of the FAA Administrator. Subtitle VII: Aviation Programs, describes in more detail the scope of the Agency's authority.

We are issuing this rulemaking under the authority described in subtitle VII, part A, subpart III, section 44701: ``General requirements.'' Under that section, Congress charges the FAA with promoting safe flight of civil aircraft in air commerce by prescribing regulations for practices, methods, and procedures the Administrator finds necessary for safety in air commerce. This regulation is within the scope of that authority because it addresses an unsafe condition that is likely to exist or develop on products identified in this rulemaking action.

Regulatory Findings

This AD will not have federalism implications under Executive Order 13132. This AD will not have a substantial direct effect on the States, on the relationship between the national government and the States, or on the distribution of power and responsibilities among the various levels of government.

For the reasons discussed above, I certify that this AD:

(1) Is not a ``significant regulatory action'' under Executive

Order 12866,

(2) Is not a ``significant rule'' under DOT Regulatory Policies and

Procedures (44 FR 11034, February 26, 1979),

(3) Will not affect intrastate aviation in Alaska, and

(4) Will not have a significant economic impact, positive or negative, on a substantial number of small entities under the criteria of the Regulatory Flexibility Act.

List of Subjects in 14 CFR Part 39

Air transportation, Aircraft, Aviation safety, Incorporation by reference, Safety.

Adoption of the Amendment 0

Accordingly, under the authority delegated to me by the Administrator, the FAA amends 14 CFR part 39 as follows:

PART 39--AIRWORTHINESS DIRECTIVES 0 1. The authority citation for part 39 continues to read as follows:

Authority: 49 U.S.C. 106(g), 40113, 44701.

Sec. 39.13 [Amended] 0 2. The FAA amends Sec. 39.13 by adding the following new airworthiness directive (AD): 2011-01-09 B/E Aerospace: Amendment 39-16562; Docket No. FAA-2010- 0797; Directorate Identifier 2010-NM-141-AD.

Effective Date

(a) This AD is effective February 9, 2011.

Affected ADs

(b) None.

Applicability

(c) This AD applies to B/E Aerospace protective breathing equipment (PBE) units having part number (P/N) 119003-11. These PBE units may be installed on (or carried or stowed on board), but not limited to, various transport category airplanes, certificated in any category, identified in but not limited to the airplanes of the manufacturers specified in Table 1 of this AD.

Table 1--Affected Manufacturers

Manufacturers

Airbus

ATR

Boeing

Bombardier

Embraer

Fokker

Hawker Beechcraft

Subject

(d) Air Transport Association (ATA) of America Code 35: Oxygen.

Unsafe Condition

(e) This AD results from reports of potentially defective potassium superoxide canisters used in PBE units, which could result in an exothermic reaction and ignition. The Federal Aviation

Administration is issuing this AD to prevent PBE units from igniting, which could result in a fire and possible injury to the flightcrew or other persons.

Compliance

(f) You are responsible for having the actions required by this

AD performed within the compliance times specified, unless the actions have already been done.

Inspection

(g) Within 120 days after the effective date of this AD, inspect to determine the serial number of the PBE units installed in the aircraft, in accordance with the Accomplishment Instructions of B/E

Aerospace Service Bulletin 119003-35-5, dated April 19, 2010. A review of airplane records is acceptable in lieu of this inspection if the serial numbers of the PBE can be conclusively determined from that review.

(1) For any PBE that has a serial number from 003-50730M to 003- 51329M inclusive: Before further flight, replace the PBE with a serviceable PBE, except as provided by paragraph (g)(2) of this AD.

(2) For any PBE that has a label showing that it has been restored in accordance with B/E Aerospace Service Bulletin 119003- 35-6: The replacement has been done, and no further action is required by paragraph (g) of this AD.

(3) For any PBE not having a serial number from 003-50730M to 003-51329M inclusive: No further action is required by paragraph (g) of this AD.

Parts Installation

(h) As of the effective date of this AD, no person may install a

PBE unit having P/N 119003-11 with a serial number ranging from 003- 50730M to 003-51329M inclusive, unless it has a label showing it has been restored in accordance with B/E Aerospace Service Bulletin 119003-35-6, dated May 21, 2010.

Alternative Methods of Compliance (AMOCs)

(i)(1) The Manager, Wichita Aircraft Certification Office (ACO),

FAA, has the authority to approve AMOCs for this AD, if requested using the procedures found in 14 CFR 39.19. Send information to

ATTN: David Fairback, Aerospace Engineer, Systems and Propulsion

Branch, ACE-116W, FAA, Wichita Aircraft Certification Office (ACO), 1801 Airport Road, Room 100, Mid-Continent Airport, Wichita, Kansas 67209; telephone (316) 946-4154; fax (316) 946-4107; e-mail

David.Fairback@faa.gov.

(2) To request a different method of compliance or a different compliance time for this AD, follow the procedures in 14 CFR 39.19.

Before using any approved AMOC on any airplane to which the AMOC applies, notify your principal maintenance inspector (PMI) or principal avionics inspector (PAI), as appropriate, or lacking a principal inspector, your local Flight Standards District Office.

The AMOC approval letter must specifically reference this AD.

Related Information

(j) For more information about this AD, contact David Fairback,

Aerospace Engineer, Systems and Propulsion Branch, ACE-116W,

Page 437

FAA, Wichita Aircraft Certification Office (ACO), 1801 Airport Road,

Room 100, Mid-Continent Airport, Wichita, Kansas 67209; telephone

(316) 946-4154; fax (316) 946-4107.

Material Incorporated by Reference

(k) You must use B/E Aerospace Service Bulletin 119003-35-5, dated April 19, 2010, to do the actions required by this AD, unless the AD specifies otherwise.

(1) The Director of the Federal Register approved the incorporation by reference of B/E Aerospace Service Bulletin 119003- 35-5, dated April 19, 2010, under 5 U.S.C. 552(a) and 1 CFR part 51.

(2) For service information identified in this AD, contact B/E

Aerospace, Inc., Commercial Aircraft Products Group, RGA Department, 10800 Pflumm Road, Lenexa, KS 66215; telephone (913) 338-7378; fax

(913) 469-8419; Internet http://www.beaerospace.com.

(3) You may review copies of the service information at the FAA,

Transport Airplane Directorate, 1601 Lind Avenue, SW., Renton,

Washington. For information on the availability of this material at the FAA, call 425-227-1221.

(4) You may also review copies of the service information that is incorporated by reference at the National Archives and Records

Administration (NARA). For information on the availability of this material at an NARA facility, call 202-741-6030, or go to http:// www.archives.gov/federal_register/code_of_federal_regulations/ ibr_locations.html.

Issued in Renton, Washington, on December 17, 2010.

Ali Bahrami,

Manager, Transport Airplane Directorate, Aircraft Certification

Service.

FR Doc. 2010-32994 Filed 1-4-11; 8:45 am

BILLING CODE 4910-13-P