Airworthiness directives: Boeing,

[Federal Register: July 13, 2001 (Volume 66, Number 135)]

[Rules and Regulations]

[Page 36699-36700]

From the Federal Register Online via GPO Access [wais.access.gpo.gov]

[DOCID:fr13jy01-3]

DEPARTMENT OF TRANSPORTATION

Federal Aviation Administration

14 CFR Part 39

[Docket No. 2000-NM-236-AD; Amendment 39-12314; AD 2001-14-04]

RIN 2120-AA64

Airworthiness Directives; Boeing Model 767-300 Series Airplanes Modified by Supplemental Type Certificate ST00118SE

AGENCY: Federal Aviation Administration, DOT.

ACTION: Final rule.

SUMMARY: This amendment adopts a new airworthiness directive (AD), applicable to all Boeing Model 767-300 series airplanes modified by Supplemental Type Certificate ST00118SE, that requires modification of the in-flight entertainment (IFE) system and revision of the Airplane Flight Manual. This action is necessary to ensure that the flight crew is able to remove electrical power from the IFE system when necessary and is advised of appropriate procedures for such action. Inability to remove power from the IFE system during a non-normal or emergency situation could result in inability to control smoke or fumes in the airplane flight deck or cabin. This action is intended to address the identified unsafe condition.

DATES: Effective August 17, 2001.

The incorporation by reference of certain publications listed in the regulations is approved by the Director of the Federal Register as of August 17, 2001.

ADDRESSES: The service information referenced in this AD may be obtained from Matsushita Avionics System Corporation, 22333 29th Drive SE, Bothell, Washington 98021. This information may be examined at the Federal Aviation Administration (FAA), Transport Airplane Directorate, Rules Docket, 1601 Lind Avenue, SW., Renton, Washington; or at the Office of the Federal Register, 800 North Capitol Street, NW., suite 700, Washington, DC.

FOR FURTHER INFORMATION CONTACT: Stephen S. Oshiro, Aerospace Engineer, Systems and Equipment Branch, ANM-130S, FAA, Seattle Aircraft Certification Office, 1601 Lind Avenue, SW., Renton, Washington 98055- 4056; telephone (425) 227-2793; fax (425) 227-1181.

SUPPLEMENTARY INFORMATION: A proposal to amend part 39 of the Federal Aviation Regulations (14 CFR part 39) to include an airworthiness directive (AD) that is applicable to all Boeing Model 767-300 series airplanes modified by Supplemental Type Certificate (STC) ST00118SE was published in the Federal Register on March 29, 2001 (66 FR 17115). That action proposed to require modification of the in-flight entertainment (IFE) system and revision of the Airplane Flight Manual (AFM).

Comments

Interested persons have been afforded an opportunity to participate in the making of this amendment. No comments were submitted in response to the proposal or the FAA's determination of the cost to the public.

Conclusion

After careful review of the available data, the FAA has determined that air safety and the public interest require the adoption of the rule as proposed.

Cost Impact

There are approximately 20 Model 767-300 series airplanes modified by STC ST00118SE in the worldwide fleet. The FAA estimates that no airplanes of U.S. registry will be affected by this AD. All airplanes included in the applicability of this AD currently are operated by non- U.S. operators under foreign registry; therefore, they are not directly affected by this AD. However, the FAA considers that this AD is necessary to ensure that the unsafe condition is addressed in the event that any of these subject airplanes are imported and placed on the U.S. Register in the future.

Should an affected airplane be imported and placed on the U.S. Register in the future, it will take approximately 50 work hours per airplane to accomplish the required modification, at an average labor rate of $60 per work hour. Required parts will be provided at no charge to the operator. Based on these figures, the cost impact of the required modification will be $3,000 per airplane.

Should an affected airplane be imported and placed on the U.S. Register in the future, it will take approximately 1 work hour per airplane to accomplish the required AFM revision, at an average labor rate of $60 per work hour. Based on these figures, the cost impact of the required AFM revision will be $60 per airplane.

The cost impact figures discussed above are based on assumptions that no operator has yet accomplished any of the requirements of this AD action, and that no operator would accomplish those actions in the future if this AD were not adopted. The cost impact figures discussed in AD rulemaking actions represent only the time necessary to perform the specific actions actually required by the AD. These figures typically do not include incidental costs, such as the time required to gain access and close up, planning time, or time necessitated by other administrative actions.

Regulatory Impact

The regulations adopted herein will not have a substantial direct effect on the States, on the relationship between the national Government and the States, or on the distribution of power and responsibilities among the various levels of government. Therefore, it is determined that this final rule does not have federalism implications under Executive Order 13132.

For the reasons discussed above, I certify that this action (1) is not a ``significant regulatory action'' under Executive Order 12866; (2) is not a ``significant rule'' under DOT Regulatory Policies and Procedures (44 FR 11034, February 26, 1979); and (3) will not have a significant economic impact, positive or negative, on a substantial number of small entities under the criteria of the Regulatory Flexibility Act. A final evaluation has been prepared for this action and it is contained in the Rules Docket. A copy of it may be obtained from the Rules Docket at the location provided under the caption ADDRESSES.

List of Subjects in 14 CFR Part 39

Air transportation, Aircraft, Aviation safety, Incorporation by reference, Safety.

Adoption of the Amendment

Accordingly, pursuant to the authority delegated to me by the Administrator, the Federal Aviation Administration amends part 39 of the Federal Aviation Regulations (14 CFR part 39) as follows:

PART 39--AIRWORTHINESS DIRECTIVES

1. The authority citation for part 39 continues to read as follows:

   Authority: 49 U.S.C. 106(g), 40113, 44701.

   [[Page 36700]]

   Sec. 39.13 [Amended]

2. Section 39.13 is amended by adding the following new airworthiness directive:

   2001-14-04 Boeing: Amendment 39-12314. Docket 2000-NM-236-AD.

   Applicability: Model 767-300 series airplanes modified by Supplemental Type Certificate (STC) ST00118SE; certificated in any category.

   Note 1: This AD applies to each airplane identified in the preceding applicability provision, regardless of whether it has been otherwise modified, altered, or repaired in the area subject to the requirements of this AD. For airplanes that have been modified, altered, or repaired so that the performance of the requirements of this AD is affected, the owner/operator must request approval for an alternative method of compliance in accordance with paragraph (c) of this AD. The request should include an assessment of the effect of the modification, alteration, or repair on the unsafe condition addressed by this AD; and, if the unsafe condition has not been eliminated, the request should include specific proposed actions to address it.

   Compliance: Required as indicated, unless accomplished previously.

   To ensure that the flight crew is able to remove electrical power from the in-flight entertainment (IFE) system when necessary and is advised of appropriate procedures for such action; accomplish the following:

   Modification and Airplane Flight Manual Revision

   (a) Within 18 months after the effective date of this AD, accomplish paragraphs (a)(1) and (a)(2) of this AD.

   (1) Modify the IFE system installed on the airplane in accordance with Matsushita Avionics Systems Corporation Service Bulletin S2GFAB767-23-1, dated February 7, 2001.

   (2) Revise the procedures under ``Electrical Smoke or Fire'' in the ``Emergency Procedures'' section of the FAA-approved Airplane Flight Manual (AFM) to include the following information. This may be accomplished by inserting a copy of this AD into the AFM.

   ``If Smoke Source Cannot Be Located:

   Utility bus switches--Off

   Establish communications with cabin crew.

   Instruct cabin crew to place in-flight entertainment (IFE) system Master Power Switch in ``OFF'' position.

   Obtain confirmation from cabin crew that electrical power to the IFE system has been removed.''

   Spares

   (b) As of the effective date of this AD, no person shall install an IFE system in accordance with STC ST00118SE on any airplane, unless it is modified and the AFM is revised in accordance with this AD.

   Alternative Methods of Compliance

   (c) An alternative method of compliance or adjustment of the compliance time that provides an acceptable level of safety may be used if approved by the Manager, Seattle Aircraft Certification Office (ACO), FAA. Operators shall submit their requests through an appropriate FAA Principal Maintenance Inspector, who may add comments and then send it to the Manager, Seattle ACO.

   Note 2: Information concerning the existence of approved alternative methods of compliance with this AD, if any, may be obtained from the Seattle ACO.

   Special Flight Permits

   (d) Special flight permits may be issued in accordance with sections 21.197 and 21.199 of the Federal Aviation Regulations (14 CFR 21.197 and 21.199) to operate the airplane to a location where the requirements of this AD can be accomplished.

   Incorporation by Reference

   (e) The modification shall be done in accordance with Matsushita Avionics Systems Corporation Service Bulletin S2GFAB767-23-1, dated February 7, 2001. This incorporation by reference was approved by the Director of the Federal Register in accordance with 5 U.S.C. 552(a) and 1 CFR part 51. Copies may be obtained from Matsushita Avionics Systems Corporation, 22333 29th Drive SE, Bothell, Washington 98021. Copies may be inspected at the FAA, Transport Airplane Directorate, 1601 Lind Avenue, SW., Renton, Washington; or at the Office of the Federal Register, 800 North Capitol Street, NW., suite 700, Washington, DC.

   Effective Date

   (f) This amendment becomes effective on August 17, 2001.

   Issued in Renton, Washington, on June 29, 2001. Vi L. Lipski, Manager, Transport Airplane Directorate, Aircraft Certification Service.

   [FR Doc. 01-17157Filed7-12-01; 8:45 am]

   BILLING CODE 4910-13-U