Airworthiness directives: Cessna,
[Federal Register: November 2, 2007 (Volume 72, Number 212)]
[Proposed Rules]
[Page 62143-62145]
From the Federal Register Online via GPO Access [wais.access.gpo.gov]
[DOCID:fr02no07-14]
Proposed Rules Federal Register
This section of the FEDERAL REGISTER contains notices to the public of the proposed issuance of rules and regulations. The purpose of these notices is to give interested persons an opportunity to participate in the rule making prior to the adoption of the final rules.
[[Page 62143]]
DEPARTMENT OF TRANSPORTATION
Federal Aviation Administration
[Docket No. FAA-2007-29317; Directorate Identifier 2007-CE-079-AD]
RIN 2120-AA64
Airworthiness Directives; Cessna Aircraft Company Model 172 and 182 Series Airplanes
AGENCY: Federal Aviation Administration (FAA), Department of Transportation (DOT).
ACTION: Notice of proposed rulemaking (NPRM).
SUMMARY: We propose to adopt a new airworthiness directive (AD) for certain Cessna Aircraft Company Model 172 and 182 series airplanes that are equipped with the BRS-172 and BRS-182 Parachute System. This proposed AD would require the replacement of the pick-up collar support and nylon screws for the BRS-172 and BRS-182 Parachute System. This proposed AD results from notification by Ballistic Recovery Systems, Inc. (BRS) that the pick-up collar assembly may prematurely move off the launch tube and adversely affect rocket trajectory during deployment. We are proposing this AD to prevent premature separation of the collar. This condition could result in the parachute failing to successfully deploy.
DATES: We must receive comments on this proposed AD by December 3, 2007.
ADDRESSES: Use one of the following addresses to comment on this proposed AD:
Federal eRulemaking Portal: Go to http://www.regulations.gov. Follow the instructions for submitting comments.
Mail: U.S. Department of Transportation, Docket Operations, M-30, West Building Ground Floor, Room W12-140, 1200 New Jersey Avenue, SE., Washington, DC 20590.
Fax: (202) 493-2251.
Hand Delivery: U.S. Department of Transportation, Docket Operations, M-30, West Building Ground Floor, Room W12-140, 1200 New Jersey Avenue, SE., Washington, DC 20590, between 9 a.m. and 5 p.m., Monday through Friday, except Federal holidays.
For service information identified in this proposed AD, contact Ballistic Recovery Systems, Inc., 300 Airport Road, South Saint Paul, MN 55075-3551; telephone: (651) 457-7491; fax: (651) 457-8651.
FOR FURTHER INFORMATION CONTACT: Gregory Michalik, Senior Aerospace Engineer, FAA, 2300 East Devon Avenue, Des Plaines, Illinois, 60018; telephone: (847) 294-7135; fax: (847) 294-7834; e-mail: gregory.michalik@faa.gov.
SUPPLEMENTARY INFORMATION:
Comments Invited
We invite you to send any written relevant data, views, or arguments regarding this proposed AD. Send your comments to an address listed under the ADDRESSES section. Include the docket number, ``FAA- 2007-29317; Directorate Identifier 2007-CE-079-AD'' at the beginning of your comments. We specifically invite comments on the overall regulatory, economic, environmental, and energy aspects of the proposed AD. We will consider all comments received by the closing date and may amend the proposed AD in light of those comments.
We will post all comments we receive, without change, to http://www.regulations.gov , including any personal information you provide. We
will also post a report summarizing each substantive verbal contact we receive concerning this proposed AD.
Discussion
We have been notified by Ballistic Recovery Systems, Inc. of a concern similar to that which prompted AD 2007-14-03, dated August 16, 2007, on the Cirrus Airplane Parachute System (CAPS), where the parachute failed to successfully deploy. Testing indicates that the force of the rocket ignition and rocket blast may prematurely break the nylon pick up collar/support screws. When functioning properly the screws should not break until impacted by a flange at the rocket base. A prematurely separated collar/support may bind on the rocket as it slides down toward the flange at the base of the rocket. This may alter the direction of the rocket.
This condition, if not corrected, could result in the parachute failing to successfully deploy upon activation.
Relevant Service Information
We have reviewed Ballistic Recovery Systems, Inc. Service Bulletins SB 07-01, dated June 8, 2007; and SB 07-02, dated June 8, 2007. The service information describes procedures for the replacement of the pick-up collar support and screws.
FAA's Determination and Requirements of the Proposed AD
We are proposing this AD because we evaluated all information and determined the unsafe condition described previously is likely to exist or develop on other products of the same type design. This proposed AD would require the replacement of the pick-up collar support and screws for the BRS-172 and BRS-182 Parachute System.
The BRS-172 and BRS-182 Parachute System could also be installed on Cessna 150 series airplanes and Symphony Aircraft Industries Models OMF-100-160 and SA 160 airplanes. The corrective actions proposed in this NPRM are specific to the Cessna 172 and 182 series airplanes. We are evaluating these other BRS installations and, based on this evaluation, may consider additional rulemaking on this subject.
Costs of Compliance
We estimate that this proposed AD would affect 54 airplanes in the U.S. registry.
We estimate the following costs to do the proposed modification:
Total cost per Total cost on Labor cost
Parts cost
airplane U.S. operators
1 work-hour x $80 per hour = $80.............. N/A.............................
$80
$4,320
[[Page 62144]]
Note: BRS will provide warranty credit to the extent noted in Ballistic Recovery Systems, Inc. Service Bulletins SB 07-01 and SB 07-02, both dated June 8, 2007.
Authority for This Rulemaking
Title 49 of the United States Code specifies the FAA's authority to issue rules on aviation safety. Subtitle I, Section 106, describes the authority of the FAA Administrator. Subtitle VII, Aviation Programs, describes in more detail the scope of the Agency's authority.
We are issuing this rulemaking under the authority described in Subtitle VII, Part A, Subpart III, Section 44701, ``General requirements.'' Under that section, Congress charges the FAA with promoting safe flight of civil aircraft in air commerce by prescribing regulations for practices, methods, and procedures the Administrator finds necessary for safety in air commerce. This regulation is within the scope of that authority because it addresses an unsafe condition that is likely to exist or develop on products identified in this rulemaking action.
Regulatory Findings
We have determined that this proposed AD would not have federalism implications under Executive Order 13132. This proposed AD would not have a substantial direct effect on the States, on the relationship between the national Government and the States, or on the distribution of power and responsibilities among the various levels of government.
For the reasons discussed above, I certify that the proposed regulation:
1. Is not a ``significant regulatory action'' under Executive Order 12866;
2. Is not a ``significant rule'' under the DOT Regulatory Policies and Procedures (44 FR 11034, February 26, 1979); and
3. Will not have a significant economic impact, positive or negative, on a substantial number of small entities under the criteria of the Regulatory Flexibility Act.
We prepared a regulatory evaluation of the estimated costs to comply with this proposed AD and placed it in the AD docket.
Examining the AD Docket
You may examine the AD docket that contains the proposed AD, the regulatory evaluation, any comments received, and other information on the Internet at http://www.regulations.gov; or in person at the Docket
Management Facility between 9 a.m. and 5 p.m., Monday through Friday, except Federal holidays. The Docket Office (telephone (800) 647-5527) is located at the street address stated in the ADDRESSES section. Comments will be available in the AD docket shortly after receipt.
List of Subjects in 14 CFR Part 39
Air transportation, Aircraft, Aviation safety, Safety.
The Proposed Amendment
Accordingly, under the authority delegated to me by the Administrator, the FAA proposes to amend 14 CFR part 39 as follows:
PART 39--AIRWORTHINESS DIRECTIVES
1. The authority citation for part 39 continues to read as follows:
Authority: 49 U.S.C. 106(g), 40113, 44701.
Sec. 39.13 [Amended]
2. The FAA amends Sec. 39.13 by adding the following new AD:
Cessna Aircraft Company: Docket No. FAA-2007-29317; Directorate Identifier 2007-CE-079-AD.
Comments Due Date
(a) We must receive comments on this airworthiness directive (AD) action by December 3, 2007.
Affected ADs
(b) None.
Applicability
(c) This AD applies to the following airplane models, all serial numbers, certificated in any category, that are equipped with:
(1) BRS-172 Parachute System installed via Supplemental Type Certificate (STC) SA01679CH, or
(2) BRS-182 Parachute System installed via STC SA01999CH.
Cessna 172 models
Cessna 182 models
172....................................... 182 172A...................................... 182A 172B...................................... 182B 172C...................................... 182C 172D...................................... 182D 172E...................................... 182E 172F (USAF T-41A)......................... 182F 172G...................................... 182G 172H (USAF T-41A)......................... 182H 172I...................................... 182J 172K...................................... 182K 172L...................................... 182L 172M...................................... 182M 172N...................................... 182N 172P...................................... 182P 172Q...................................... 182Q 172R...................................... 182R 172S...................................... 182S 182T R182 T182 TR182 T182T
Unsafe Condition
(d) This AD results from notification by Ballistic Recovery Systems, Inc. (BRS) that the pick-up collar assembly may prematurely move off the launch tube and adversely affect rocket trajectory during deployment. We are issuing this AD to prevent premature separation of the collar. This condition could result in the parachute failing to successfully deploy.
Compliance
(e) To address this problem, you must do the following, unless already done:
Actions
Compliance
Procedures
Remove and replace the pick-up Within the next 25 (i) For Cessna collar support and two
hours time-in- Model 172 retaining screws.
service after the airplanes follow effective date of BRS SB 07-01, this AD.
dated June 8, 2007. (ii) For Cessna Model 182 airplanes, follow BRS SB 07-02, dated June 8, 2007.
Alternative Methods of Compliance (AMOCs)
(f) The Manager, Chicago Aircraft Certification Office, FAA, has the authority to approve AMOCs for this AD, if requested using the procedures found in 14 CFR 39.19. Send information to ATTN: Gregory Michalik, Senior Aerospace Engineer, FAA, 2300 East Devon Avenue, Des Plaines, Illinois 60018; telephone: (847) 294-7135; fax: (847) 294-7834; e-mail: gregory.michalik@faa.gov. Before using any approved AMOC on any airplane to which the AMOC applies, notify your appropriate principal inspector (PI) in the FAA Flight Standards District Office (FSDO), or lacking a PI, your local FSDO.
Related Information
(g) To get copies of the service information referenced in this AD, contact Ballistic Recovery Systems, Inc., 300 Airport Road, South Saint Paul, MN 55075-3551; telephone: (651) 457-7491; fax: (651) 457-8651. To view the AD docket, go to U.S. Department of Transportation, Docket Operations, M-30, West Building Ground Floor, Room W12-140, 1200 New Jersey Avenue, SE., Washington, DC 20590, or on the Internet at http://www.regulations.gov. The docket number is
Docket No. FAA-2007-29317; Directorate Identifier 2007-CE-079-AD.
[[Page 62145]]
Issued in Kansas City, Missouri, on October 26, 2007. Kim Smith, Manager, Small Airplane Directorate, Aircraft Certification Service. [FR Doc. E7-21571 Filed 11-1-07; 8:45 am]
BILLING CODE 4910-13-P
