Airworthiness directives: Honeywell,

[Federal Register: May 9, 2002 (Volume 67, Number 90)]

[Rules and Regulations]

[Page 31111-31113]

From the Federal Register Online via GPO Access [wais.access.gpo.gov]

[DOCID:fr09my02-1]

Rules and Regulations Federal Register

This section of the FEDERAL REGISTER contains regulatory documents having general applicability and legal effect, most of which are keyed to and codified in the Code of Federal Regulations, which is published under 50 titles pursuant to 44 U.S.C. 1510.

The Code of Federal Regulations is sold by the Superintendent of Documents. Prices of new books are listed in the first FEDERAL REGISTER issue of each week.

[[Page 31111]]

DEPARTMENT OF TRANSPORTATION

Federal Aviation Administration

14 CFR Part 39

[Docket No. 2000-NE-50-AD; Amendment 39-12742; AD 2002-09-09]

RIN 2120-AA64

Airworthiness Directives; Honeywell International, Inc., (Formerly AlliedSignal, Inc., Textron Lycoming, Avco Lycoming, and Lycoming) Former Military T53 Series Turboshaft Engines

AGENCY: Federal Aviation Administration, DOT.

ACTION: Final rule.

SUMMARY: This amendment adopts a new airworthiness directive (AD), that is applicable to Honeywell International, Inc., (formerly AlliedSignal, Inc., Textron Lycoming, Avco Lycoming, and Lycoming) former military T53 series turboshaft engines. This amendment requires conducting a revised operating cycle count (prorate) and initial and repetitive inspections for cracks of centrifugal compressor impellers. This amendment is prompted by a report of a military surplus helicopter that experienced low-cycle fatigue failure of the centrifugal compressor impeller, resulting in an uncontained engine failure. The actions specified by this AD are intended to prevent centrifugal compressor impeller failure, which can result in an uncontained engine failure, in-flight engine shutdown, or damage to the helicopter.

DATES: Effective date June 13, 2002. The incorporation by reference of certain publications listed in the regulations is approved by the Director of the Federal Register as of June 13, 2002.

ADDRESSES: The service information referenced in this AD may be obtained from Honeywell International, Inc., Attn: Data Distribution, M/S 64-3/2101-201, P.O. Box 29003, Phoenix, AZ 85038-9003; telephone: (602) 365-2493; fax: (602) 365-5577. This information may be examined, by appointment, at the Federal Aviation Administration (FAA), New England Region, Office of the Regional Counsel, 12 New England Executive Park, Burlington, MA; or at the Office of the Federal Register, 800 North Capitol Street, NW, suite 700, Washington, DC.

FOR FURTHER INFORMATION CONTACT: Robert Baitoo, Aerospace Engineer, Los Angeles Aircraft Certification Office, FAA, Transport Airplane Directorate, 3960 Paramount Blvd., Lakewood, CA 90712-4137; telephone: (562) 627-5245, fax: (562) 627-5210.

SUPPLEMENTARY INFORMATION: A proposal to amend part 39 of the Federal Aviation Regulations (14 CFR part 39) to include an AD that is applicable to Honeywell International, Inc., (formerly AlliedSignal, Inc., Textron Lycoming, Avco Lycoming, and Lycoming) former military T53 series turboshaft engines was published in the Federal Register on August 16, 2001(66 FR 42970). That action proposed to require conducting a revised operating cycle count (prorate) and initial and repetitive inspections for cracks of centrifugal compressor impellers in accordance with AlliedSignal, Inc. SB's T53-L-13B-0108, Revision 1, dated November 22, 1999; T53-L-13B/D-0108, Revision 1, dated November 22, 1999; T53-L-703-0108, Revision 1, dated November 22, 1999 and Honeywell International Inc. SB's T53-L-13B-0020, Revision 2, dated April 25, 2001; T53-L-13B/D-0020, Revision 1, dated April 25, 2001; and T53-L-703-0020, Revision 1, dated April 25, 2001.

Comments

Interested persons have been afforded an opportunity to participate in the making of this amendment. Due consideration has been given to the comment received.

One commenter believes that the AD is unnecessary. The FAA does not agree. The AD was prompted by a report of a military surplus helicopter that experienced low-cycle fatigue of the centrifugal compressor impeller, resulting in an uncontained engine failure.

After careful review of the available data, including the comment noted above, the FAA has determined that air safety and the public interest require the adoption of the rule as proposed.

Economic Analysis

The FAA estimates that there are approximately 300 Lycoming former military T53 series turboshaft engines installed on helicopters of U.S. registry, that would be affected by this AD. The FAA also estimates that it would take approximately 8 work hours per engine to accomplish an initial or repetitive inspection of the centrifugal compressor impeller, and that the average labor rate is $60 per work hour. No additional work hour cost would be incurred if the centrifugal compressor impeller is replaced during normal engine disassembly. Based on these figures, the total labor cost impact of the AD on U.S. operators for an inspection is estimated to be $144,000. The FAA estimates that operators will perform two inspections annually, and that the total annual labor cost for inspections is estimated to be $288,000. The cost of a replacement centrifugal compressor impeller is estimated to be $22,037. Assuming a loss of 50% of the life of each disk by the prorate, the total annual cost of the proposed AD on U.S. operators is estimated to be $3,593,550.

Regulatory Analysis

This final rule does not have federalism implications, as defined in Executive Order 13132, because it would not have a substantial direct effect on the States, on the relationship between the national government and the States, or on the distribution of power and responsibilities among the various levels of government. Accordingly, the FAA has not consulted with state authorities prior to publication of this final rule.

For the reasons discussed above, I certify that this action (1) is not a ``significant regulatory action'' under Executive Order 12866; (2) is not a ``significant rule'' under the DOT Regulatory Policies and Procedures (44 FR 11034, February 26, 1979); and (3) if promulgated, will not have a significant economic impact, positive or negative, on a substantial number of small entities under the criteria of the Regulatory Flexibility Act. A final evaluation has been prepared for this action and it is contained in the Rules Docket. A copy of it may be obtained by contacting the

[[Page 31112]]

Rules Docket at the location provided under the caption ADDRESSES.

List of Subjects in 14 CFR Part 39

Air transportation, Aircraft, Aviation safety, Incorporation by reference, Safety.

Adoption of the Amendment

Accordingly, pursuant to the authority delegated to me by the Administrator, the Federal Aviation Administration amends part 39 of the Federal Aviation Regulations (14 CFR part 39) as follows:

PART 39--AIRWORTHINESS DIRECTIVES

1. The authority citation for part 39 continues to read as follows:

   Authority: 49 U.S.C. 106(g), 40113, 44701.

   Sec. 39.13 [Amended]

2. Section 39.13 is amended by adding a new airworthiness directive to read as follows:

   2002-09-09 Honeywell International, Inc.: Amendment 39-12742. Docket No. 2000-NE-50-AD.

   Applicability

   This airworthiness directive (AD) is applicable to Honeywell International, Inc. (formerly AlliedSignal, Inc., Textron Lycoming, Avco Lycoming, and Lycoming) former military T53 series turboshaft engines with centrifugal compressor impellers part numbers (P/N's) 1-100-078-07 or 1-100-078-08 installed. These engines are installed on, but not limited to, Bell Helicopter Textron manufactured AH-1, UH-1, and SW-204/205 (UH-1) series surplus military helicopters that have been certified in accordance with Secs. 21.25 or 21.27 of the Federal Aviation regulations (14 CFR 21.25 or 21.27).

   Note 1: This AD applies to each engine identified in the preceding applicability provision, regardless of whether it has been modified, altered, or repaired in the area subject to the requirements of this AD. For engines that have been modified, altered, or repaired so that the performance of the requirements of this AD is affected, the owner/operator must request approval for an alternative method of compliance in accordance with paragraph (e) of this AD. The request should include an assessment of the effect of the modification, alteration, or repair on the unsafe condition addressed by this AD; and, if the unsafe condition has not been eliminated, the request should include specific proposed actions to address it.

   Compliance

   Compliance with this AD is required as indicated, unless already done.

   To prevent centrifugal compressor impeller failure, which can result in an uncontained engine failure, in-flight engine shutdown, or damage to the helicopter, do the following:

   Centrifugal Compressor Impeller Revised Operating Cycle Count

   (a) Within 25 operating cycles or 7 calendar days, whichever occurs first, after the effective date of this AD, do a revised centrifugal compressor impeller operating cycle count (prorate) in accordance with the accomplishment instructions of Honeywell International, Inc. Service Bulletin (SB) No. T53-L-13B-0020, Revision 3, dated October 25, 2001, for T53-L-13B Lycoming engines, SB No. T53-L-13B/D-0020, Revision 1, dated April 25, 2001 for T53-L- 13B/D Lycoming engines, and SB No. T53-L-703-0020, Revision 1, dated April 25, 2001 for T53-L-703 Lycoming engines.

   (b) Following the revised operating cycle count required by paragraph (a) of this AD, remove from service installed centrifugal compressor impellers that exceed their life limit or whose life cannot be determined, within 50 hours time-in-service (TIS), or 25 operating cycles, whichever occurs first and replace with a serviceable part that does not exceed the life limit.

   (c) Installation of uninstalled centrifugal compressor impellers that exceed their life limit, which is revised in accordance with paragraph (a) of this AD is prohibited.

   Centrifugal Compressor Impeller Inspections

   (d) Following the revised operating cycle count required by paragraph (a) of this AD, inspect centrifugal compressor impellers, part numbers (P/N's) 1-100-078-07 and 1-100-078-08, in accordance with the accomplishment instructions of AlliedSignal, Inc. SB No. T53-L-13B-0108, Revision 1, dated November 22, 1999, for T53-L-13B Lycoming engines; SB No. T53-L-13B/D-0108, Revision 1, dated November 22, 1999 for T53-L-13B/D Lycoming engines; or SB No. T53-L- 703-0108, Revision 1, dated November 22, 1999 for T53-L-703 Lycoming engines, as follows:

   (1) For centrifugal compressor impellers with equal to or greater than 4,600 cycles-in-service (CIS), initially inspect within 200 CIS after the effective date of this AD.

   (2) For those centrifugal compressor impellers with less than 4,600 CIS, initially inspect no later than 4,800 CIS.

   (3) Centrifugal compressor impellers found cracked must be removed from service prior to further flight and replaced with a serviceable part.

   (4) If no cracks are detected, perform repetitive inspections of the centrifugal compressor impellers at intervals not to exceed 500 CIS since last inspection.

   Alternative Methods of Compliance

   (e) An alternative method of compliance or adjustment of the compliance time that provides an acceptable level of safety may be used if approved by the Manager, Los Angeles Aircraft Certification Office (ACO). Operators must submit their requests through an appropriate FAA Principal Maintenance Inspector, who may add comments and then send it to the Manager, Los Angeles ACO.

   Note 2: Information concerning the existence of approved alternative methods of compliance with this AD, if any, may be obtained from the Los Angeles ACO.

   Special Flight Permits

   (f) Special flight permits may be issued in accordance with Secs. 21.197 and 21.199 of the Federal Aviation Regulations (14 CFR 21.197 and 21.199) to operate the airplane to a location where the requirements of this AD can be done.

   Documents That Have Been Incorporated By Reference

   (g) The inspection must be done in accordance with the following Honeywell International Inc. (HII) and AlliedSignal, Inc. (ASI) service bulletins:

   Document No.

   Pages

   Revision

   Date

   HII, SB No. T53-L-13B-0020....... All............... 3........................ Oct. 25, 2001.

   Total pages 13 HII, SB No. T53-L-13B/D-0020..... All............... 1........................ April 25, 2001.

   Total pages 12 HII, SB No. T53-L-703-0020....... All............... 1........................ April 25, 2001.

   Total pages 12 ASI.............................. 1................. Original................. July 22, 1999. SB No. T53-L-13B-0108............ 2................. 1........................ Nov. 22, 1999. 3-12.............. Original................. July 22, 1999.

   Total pages 12 ASI.............................. 1................. Original................. July 22, 1999. SB No. T53-L-13B/D-0108.......... 2................. 1........................ Nov. 22, 1999. 3-12.............. Original................. July 22, 1999.

   Total pages 12 ASI.............................. 1................. Original................. July 22, 1999. SB No. T53-L-703-0108............ 2................. 1........................ Nov. 22, 1999.

   [[Page 31113]]

   3-12.............. Original................. July 22, 1999.

   Total pages 12

   This incorporation by reference was approved by the Director of the Federal Register in accordance with 5 U.S.C. 552(a) and 1 CFR part 51. Copies may be obtained from Honeywell International, Inc., Attn: Data Distribution, M/S 64-3/2101-201, P.O. Box 29003, Phoenix, AZ 85038-9003; telephone: (602) 365-2493; fax: (602) 365-5577. Copies may be inspected, by appointment, at the FAA, New England Region, Office of the Regional Counsel, 12 New England Executive Park, Burlington, MA; or at the Office of the Federal Register, 800 North Capitol Street, NW, suite 700, Washington, DC.

   Effective Date

   (h) This amendment becomes effective on June 13, 2002.

   Issued in Burlington, Massachusetts, on April 29, 2002. Diane S. Romanosky, Acting Manager, Engine and Propeller Directorate, Aircraft Certification Service.

   [FR Doc. 02-11216Filed5-8-02; 8:45 am]

   BILLING CODE 4910-13-U