Airworthiness Directives; Hawker Beechcraft Corporation Airplanes
Federal Register, Volume 77 Issue 154 (Thursday, August 9, 2012)
Federal Register Volume 77, Number 154 (Thursday, August 9, 2012)
Proposed Rules
Pages 47568-47570
From the Federal Register Online via the Government Printing Office www.gpo.gov
FR Doc No: 2012-19541
-----------------------------------------------------------------------
DEPARTMENT OF TRANSPORTATION
Federal Aviation Administration
Docket No. FAA-2012-0829; Directorate Identifier 2012-CE-024-AD
RIN 2120-AA64
Airworthiness Directives; Hawker Beechcraft Corporation Airplanes
AGENCY: Federal Aviation Administration (FAA), DOT.
ACTION: Notice of proposed rulemaking (NPRM).
-----------------------------------------------------------------------
SUMMARY: We propose to adopt a new airworthiness directive (AD) for certain Hawker Beechcraft Corporation Model G58 airplanes. This proposed AD was prompted by notification from Hawker Beechcraft Corporation that certain affected aircraft were produced with the incorrect gauge wiring installed. This proposed AD would require replacement of the incorrect gauge wiring with the correct wiring required by type design and the aircraft's circuit protection. We are proposing this AD to correct the unsafe condition on these products.
DATES: We must receive comments on this proposed AD by September 24, 2012.
ADDRESSES: You may send comments, using the procedures found in 14 CFR 11.43 and 11.45, by any of the following methods:
Federal eRulemaking Portal: Go to http://www.regulations.gov. Follow the instructions for submitting comments.
Fax: 202-493-2251.
Mail: U.S. Department of Transportation, Docket Operations, M-30, West Building Ground Floor, Room W12-140, 1200 New Jersey Avenue SE., Washington, DC 20590.
Hand Delivery: Deliver to Mail address above between 9 a.m. and 5 p.m., Monday through Friday, except Federal holidays.
For service information identified in this proposed AD, contact Hawker Beechcraft Corporation, B091-A04, 10511 E. Central Ave., Wichita, Kansas 67206; telephone: 1 (800) 429-5372 or (316) 676-3140; fax: (316) 676-8027; email: tmdc@hawkerbeechcraft.com; or Internet: http://www.hawkerbeechcraft.com/customer_support/technical_and_field_support/. You may review copies of the referenced service information at the FAA, Small Airplane Directorate, 901 Locust, Kansas City, Missouri 64106. For information on the
Page 47569
availability of this material at the FAA, call (816) 329-4148.
Examining the AD Docket
You may examine the AD docket on the Internet at http://www.regulations.gov; or in person at the Docket Management Facility between 9 a.m. and 5 p.m., Monday through Friday, except Federal holidays. The AD docket contains this proposed AD, the regulatory evaluation, any comments received, and other information. The street address for the Docket Office (phone: 800-647-5527) is in the ADDRESSES section. Comments will be available in the AD docket shortly after receipt.
FOR FURTHER INFORMATION CONTACT: Richard Rejniak, Aerospace Engineer, Wichita Aircraft Certification Office, 1801 Airport Road, Room 100, Wichita, Kansas 67209; phone: (316) 946-4128; fax: (316) 946-4107; email: richard.rejniak@faa.gov.
SUPPLEMENTARY INFORMATION:
Comments Invited
We invite you to send any written relevant data, views, or arguments about this proposal. Send your comments to an address listed under the ADDRESSES section. Include ``Docket No. FAA-2012-0829; Directorate Identifier 2012-CE-024-AD'' at the beginning of your comments. We specifically invite comments on the overall regulatory, economic, environmental, and energy aspects of this proposed AD. We will consider all comments received by the closing date and may amend this proposed AD because of those comments.
We will post all comments we receive, without change, to http://www.regulations.gov, including any personal information you provide. We will also post a report summarizing each substantive verbal contact we receive about this proposed AD.
Discussion
We received notification from Hawker Beechcraft Corporation that their wiring fabricators created wiring bundles with the incorrect gauge wiring for the three-light strobe system of certain Model G58 airplanes. The wire used is a smaller gauge wire than required by type design and the aircraft's circuit protection is not adequate to protect the incorrect gauge wire. This condition, if not corrected, could result in smoke in the cockpit and the possible failure of the aircraft's strobe light system. The failure of the wiring for the aircraft's strobe light system could also cause potential damage to surrounding wires.
Relevant Service Information
We reviewed Hawker Beechcraft Mandatory Service Bulletin No. SB 33-
4053, dated February 2011. The service bulletin describes procedures for replacing the existing 20-gauge wire with a new wire of 18-gauge size, part number (P/N) M27500-18TE1T14, or equivalent.
FAA's Determination
We are proposing this AD because we evaluated all the relevant information and determined the unsafe condition described previously is likely to exist or develop in other products of the same type design.
Proposed AD Requirements
This proposed AD would require accomplishing the actions specified in the service information described previously.
Costs of Compliance
We estimate that this proposed AD affects 40 airplanes of U.S. registry.
We estimate the following costs to comply with this proposed AD:
Estimated Costs
----------------------------------------------------------------------------------------------------------------
Cost per Cost on U.S.
Action Labor cost Parts cost product operators
----------------------------------------------------------------------------------------------------------------
Replace supply wire of the three 16 work-hours x $85 per $50 $1,410 $56,400
light strobe system. hour = $1,360.
----------------------------------------------------------------------------------------------------------------
According to the manufacturer, some of the costs of this proposed AD may be covered under warranty, thereby reducing the cost impact on affected individuals. We do not control warranty coverage for affected individuals. As a result, we have included all costs in our cost estimate.
Authority for This Rulemaking
Title 49 of the United States Code specifies the FAA's authority to issue rules on aviation safety. Subtitle I, section 106, describes the authority of the FAA Administrator. Subtitle VII: Aviation Programs, describes in more detail the scope of the Agency's authority.
We are issuing this rulemaking under the authority described in Subtitle VII, Part A, Subpart III, Section 44701: ``General requirements.'' Under that section, Congress charges the FAA with promoting safe flight of civil aircraft in air commerce by prescribing regulations for practices, methods, and procedures the Administrator finds necessary for safety in air commerce. This regulation is within the scope of that authority because it addresses an unsafe condition that is likely to exist or develop on products identified in this rulemaking action.
Regulatory Findings
We determined that this proposed AD would not have federalism implications under Executive Order 13132. This proposed AD would not have a substantial direct effect on the States, on the relationship between the national Government and the States, or on the distribution of power and responsibilities among the various levels of government.
For the reasons discussed above, I certify this proposed regulation:
(1) Is not a ``significant regulatory action'' under Executive Order 12866,
(2) Is not a ``significant rule'' under the DOT Regulatory Policies and Procedures (44 FR 11034, February 26, 1979),
(3) Will not affect intrastate aviation in Alaska, and
(4) Will not have a significant economic impact, positive or negative, on a substantial number of small entities under the criteria of the Regulatory Flexibility Act.
List of Subjects in 14 CFR Part 39
Air transportation, Aircraft, Aviation safety, Incorporation by reference, Safety.
The Proposed Amendment
Accordingly, under the authority delegated to me by the Administrator, the FAA proposes to amend 14 CFR part 39 as follows:
PART 39--AIRWORTHINESS DIRECTIVES
-
The authority citation for part 39 continues to read as follows:
Authority: 49 U.S.C. 106(g), 40113, 44701.
Page 47570
Sec. 39.13 Amended
-
The FAA amends Sec. 39.13 by adding the following new airworthiness directive (AD):
Hawker Beechcraft Corporation Airplanes: Docket No. FAA-2012-0829; Directorate Identifier 2012-CE-024-AD.
(a) Comments Due Date
We must receive comments by September 24, 2012.
(b) Affected ADs
None.
(c) Applicability
This AD applies to Hawker Beechcraft Corporation Model G58 airplanes, serial numbers (S/N) TH-2218 through TH-2285, that are certificated in any category.
(d) Subject
Joint Aircraft System Component (JASC)/Air Transport Association (ATA) of America Code 24, Electrical power.
(e) Unsafe Condition
This AD was prompted by notification from Hawker Beechcraft Corporation that certain aircraft were produced with the incorrect gauge wiring installed. We are issuing this AD to correct the unsafe condition on these products.
(f) Compliance
Comply with this AD within the compliance times specified, unless already done.
(g) Replace Supply Wire of the Three Light Strobe System
Within the next 50 hours time-in-service (TIS) after the effective date of this AD or within the next 6 calendar months after the effective date of this AD, whichever occurs first, replace the supply wire of the three-light strobe system. Do the replacement following Hawker Beechcraft Mandatory Service Bulletin No. SB 33-
4053, dated February 2011.
(h) Special Flight Permit
Special flight permits are permitted with the following limitation: visual flight rules (VFR) day conditions.
(i) Alternative Methods of Compliance (AMOCs)
(1) The Manager, Wichita Aircraft Certification Office (ACO), FAA, has the authority to approve AMOCs for this AD, if requested using the procedures found in 14 CFR 39.19. In accordance with 14 CFR 39.19, send your request to your principal inspector or local Flight Standards District Office, as appropriate. If sending information directly to the manager of the ACO, send it to the attention of the person identified in the Related Information section of this AD.
(2) Before using any approved AMOC, notify your appropriate principal inspector, or lacking a principal inspector, the manager of the local flight standards district office/certificate holding district office.
(j) Related Information
(1) For more information about this AD, contact Richard Rejniak, Aerospace Engineer, Wichita Aircraft Certification Office, 1801 Airport Road, Room 100, Wichita, Kansas 67209; phone: (316) 946-
4128; fax: (316) 946-4107; email: richard.rejniak@faa.gov.
(2) For service information identified in this AD, contact Hawker Beechcraft Corporation, B091-A04, 10511 E. Central Ave., Wichita, Kansas 67206; telephone: 1 (800) 429-5372 or (316) 676-
3140; fax: (316) 676-8027; email: tmdc@hawkerbeechcraft.com; or Internet: http://www.hawkerbeechcraft.com/customer_support/technical_and_field_support/. You may review copies of the referenced service information at the FAA, Small Airplane Directorate, 901 Locust, Kansas City, Missouri 64106. For information on the availability of this material at the FAA, call (816) 329-4148.
Issued in Kansas City, Missouri, on August 3, 2012.
Earl Lawrence,
Manager, Small Airplane Directorate, Aircraft Certification Service.
FR Doc. 2012-19541 Filed 8-8-12; 8:45 am
BILLING CODE 4910-13-P
