Airworthiness Directives: McDonnell Douglas Model MD-90-30 Airplanes

Federal Register: March 31, 2009 (Volume 74, Number 60)

Rules and Regulations

Page 14460-14461

From the Federal Register Online via GPO Access [wais.access.gpo.gov]

DOCID:fr31mr09-3

DEPARTMENT OF TRANSPORTATION

Federal Aviation Administration 14 CFR Part 39

Docket No. FAA-2007-0074; Directorate Identifier 2007-NM-151-AD;

Amendment 39-15863; AD 2009-07-04

RIN 2120-AA64

Airworthiness Directives; McDonnell Douglas Model MD-90-30

Airplanes

AGENCY: Federal Aviation Administration (FAA), Department of

Transportation (DOT).

ACTION: Final rule.

SUMMARY: The FAA is adopting a new airworthiness directive (AD) for certain McDonnell Douglas Model MD-90-30 airplanes. This AD requires modifying the auxiliary hydraulic power system (including doing all applicable related investigative and corrective actions). This AD results from fuel system reviews conducted by the manufacturer, as well as reports of shorted wires in the right wheel well and evidence of arcing on the power cables of the auxiliary hydraulic pump. We are issuing this AD to prevent shorted wires or electrical arcing at the auxiliary hydraulic pump, which could result in a fire in the wheel well; and to reduce the potential of an ignition source adjacent to the fuel tanks, which, in combination with flammable fuel vapors, could result in a fuel tank explosion and consequent loss of the airplane.

DATES: This AD becomes effective May 5, 2009.

The Director of the Federal Register approved the incorporation by reference of a certain publication listed in the AD as of May 5, 2009.

ADDRESSES: For service information identified in this AD, contact

Boeing Commercial Airplanes, Attention: Data & Services Management, 3855 Lakewood Boulevard, MC D800-0019, Long Beach, California 90846- 0001; telephone 206-544-5000, extension 2; fax 206-766-5683; e-mail dse.boecom@boeing.com; Internet https://www.myboeingfleet.com.

Examining the AD Docket

You may examine the AD docket on the Internet at http:// www.regulations.gov; or in person at the Docket Management Facility between 9 a.m. and 5 p.m., Monday through Friday, except Federal holidays. The AD docket contains this AD, the regulatory evaluation, any comments received, and other information. The address for the

Docket Office (telephone 800-647-5527) is the Document Management

Facility, U.S. Department of Transportation, Docket Operations, M-30,

West Building Ground Floor, Room W12-140, 1200 New Jersey Avenue, SE.,

Washington, DC 20590.

FOR FURTHER INFORMATION CONTACT: Ken Sujishi, Aerospace Engineer, Cabin

Safety/Mechanical and Environmental Systems Branch, ANM-150L, FAA, Los

Angeles Aircraft Certification Office, 3960 Paramount Boulevard,

Lakewood, California 90712-4137; telephone (562) 627-5353; fax (562) 627-5210.

SUPPLEMENTARY INFORMATION:

Discussion

The FAA issued a supplemental notice of proposed rulemaking (NPRM) to amend 14 CFR part 39 to include an AD that would apply to certain

McDonnell Douglas Model MD-90-30 airplanes. That supplemental NPRM was published in the Federal Register on December 19, 2008 (73 FR 77555).

That supplemental NPRM proposed to require modifying the auxiliary hydraulic system (including doing all applicable related investigative and corrective actions).

Comments

We provided the public the opportunity to participate in the development of this AD. No comments have been received on the supplemental NPRM or on the determination of the cost to the public.

Conclusion

We have carefully reviewed the available data and determined that air safety and the public interest require adopting the AD as proposed in the supplemental NPRM.

Costs of Compliance

There are about 110 airplanes of the affected design in the worldwide fleet. This AD affects about 16 airplanes of U.S. registry.

The actions take between 3 and 7 work-hours per airplane, depending on the configuration, at an average labor rate of $80 per work-hour.

Required parts cost up to $5,343 per airplane. Based on these figures, the estimated cost of the AD for U.S. operators is up to $94,448, or

$5,903 per airplane.

Authority for This Rulemaking

Title 49 of the United States Code specifies the FAA's authority to issue rules on aviation safety. Subtitle I, Section 106, describes the authority of the FAA Administrator. Subtitle VII, Aviation Programs, describes in more detail the scope of the Agency's authority.

We are issuing this rulemaking under the authority described in

Subtitle VII, Part A, Subpart III, Section 44701, ``General requirements.'' Under that section, Congress charges the FAA with promoting safe flight of civil aircraft in air commerce by prescribing regulations for practices, methods, and procedures the Administrator finds necessary for safety in air commerce. This regulation is within the scope of that authority because it addresses an unsafe condition that is likely to exist or develop on products identified in this rulemaking action.

Regulatory Findings

We have determined that this AD will not have federalism implications under Executive Order 13132. This AD will not have a substantial direct effect on the States, on the relationship between the national government and the States, or on the distribution of power and responsibilities among the various levels of government.

For the reasons discussed above, I certify that this AD:

(1) Is not a ``significant regulatory action'' under Executive

Order 12866;

(2) Is not a ``significant rule'' under DOT Regulatory Policies and

Procedures (44 FR 11034, February 26, 1979); and

(3) Will not have a significant economic impact, positive or negative, on a substantial number of small entities under the criteria of the Regulatory Flexibility Act.

We prepared a regulatory evaluation of the estimated costs to comply with this AD and placed it in the AD docket. See the ADDRESSES section for a location to examine the regulatory evaluation.

List of Subjects in 14 CFR Part 39

Air transportation, Aircraft, Aviation safety, Incorporation by reference, Safety.

Adoption of the Amendment 0

Accordingly, under the authority delegated to me by the Administrator, the FAA amends 14 CFR part 39 as follows:

PART 39--AIRWORTHINESS DIRECTIVES 0 1. The authority citation for part 39 continues to read as follows:

Page 14461

Authority: 49 U.S.C. 106(g), 40113, 44701.

Sec. 39.13 [Amended] 0 2. The Federal Aviation Administration (FAA) amends Sec. 39.13 by adding the following new airworthiness directive (AD): 2009-07-04 McDonnell Douglas: Amendment 39-15863. Docket No. FAA- 2007-0074; Directorate Identifier 2007-NM-151-AD.

Effective Date

(a) This AD becomes effective May 5, 2009.

Affected ADs

(b) None.

Applicability

(c) This AD applies to McDonnell Douglas Model MD-90-30 airplanes, certificated in any category; as identified in Boeing

Alert Service Bulletin MD90-29A021, Revision 1, dated August 29, 2008.

Unsafe Condition

(d) This AD results from fuel system reviews conducted by the manufacturer, as well as reports of shorted wires in the right wheel well and evidence of arcing on the power cables of the auxiliary hydraulic pump. We are issuing this AD to prevent shorted wires or electrical arcing at the auxiliary hydraulic pump, which could result in a fire in the wheel well. We are also issuing this AD to reduce the potential of an ignition source adjacent to the fuel tanks, which, in combination with flammable fuel vapors, could result in a fuel tank explosion and consequent loss of the airplane.

Compliance

(e) You are responsible for having the actions required by this

AD performed within the compliance times specified, unless the actions have already been done.

Modification

(f) Within 18 months after the effective date of this AD, modify the auxiliary hydraulic power system and do all applicable related investigative and corrective actions by accomplishing all applicable actions specified in the Accomplishment Instructions of Boeing Alert

Service Bulletin MD90-29A021, Revision 1, dated August 29, 2008. Do all applicable related investigative and corrective actions before further flight.

Alternative Methods of Compliance (AMOCs)

(g)(1) The Manager, Los Angeles Aircraft Certification Office,

FAA, ATTN: Ken Sujishi, Aerospace Engineer, Cabin Safety/Mechanical and Environmental Systems Branch, ANM-150L, FAA, Los Angeles

Aircraft Certification Office, 3960 Paramount Boulevard, Lakewood,

California 90712-4137; telephone (562) 627-5353; fax (562) 627-5210; has the authority to approve AMOCs for this AD, if requested in accordance with the procedures found in 14 CFR 39.19.

(2) To request a different method of compliance or a different compliance time for this AD, follow the procedures in 14 CFR 39.19.

Before using any approved AMOC on any airplane to which the AMOC applies, notify your appropriate principal inspector (PI) in the FAA

Flight Standards District Office (FSDO), or lacking a PI, your local

FSDO.

Material Incorporated by Reference

(h) You must use Boeing Alert Service Bulletin MD90-29A021,

Revision 1, dated August 29, 2008, to do the actions required by this AD, unless the AD specifies otherwise.

(1) The Director of the Federal Register approved the incorporation by reference of this service information under 5

U.S.C. 552(a) and 1 CFR part 51.

(2) For service information identified in this AD, contact

Boeing Commercial Airplanes, Attention: Data & Services Management, 3855 Lakewood Boulevard, MC D800-0019, Long Beach, California 90846- 0001; telephone 206-544-5000, extension 2; fax 206-766-5683; e-mail dse.boecom@boeing.com; Internet https://www.myboeingfleet.com.

(3) You may review copies of the service information at the FAA,

Transport Airplane Directorate, 1601 Lind Avenue SW., Renton,

Washington. For information on the availability of this material at the FAA, call 425-227-1221 or 425-227-1152.

(4) You may also review copies of the service information that is incorporated by reference at the National Archives and Records

Administration (NARA). For information on the availability of this material at NARA, call 202-741-6030, or go to: http:// www.archives.gov/federal_register/code_of_federal_regulations/ ibr_locations.html.

Issued in Renton, Washington, on March 18, 2009.

Ali Bahrami,

Manager, Transport Airplane Directorate, Aircraft Certification

Service.

FR Doc. E9-6752 Filed 3-30-09; 8:45 am

BILLING CODE 4910-13-P