Airworthiness Directives; Turbomeca S.A. Turboshaft Engines

Federal Register, Volume 77 Issue 178 (Thursday, September 13, 2012)

Federal Register Volume 77, Number 178 (Thursday, September 13, 2012)

Proposed Rules

Pages 56585-56586

From the Federal Register Online via the Government Printing Office www.gpo.gov

FR Doc No: 2012-22530

-----------------------------------------------------------------------

DEPARTMENT OF TRANSPORTATION

Federal Aviation Administration

14 CFR Part 39

Docket No. FAA-2012-0901; Directorate Identifier 2012-NE-19-AD

RIN 2120-AA64

Airworthiness Directives; Turbomeca S.A. Turboshaft Engines

AGENCY: Federal Aviation Administration (FAA), DOT.

ACTION: Notice of proposed rulemaking (NPRM).

-----------------------------------------------------------------------

SUMMARY: We propose to adopt a new airworthiness directive (AD) for all Turbomeca S.A. Arriel 1A1, 1A2, 1B, 1C, 1C1, 1C2, 1D, 1D1, 1E2, 1K1, 1S, and 1S1 turboshaft engines. This proposed AD was prompted by several reports of uncommanded in-flight shutdown (IFSD) on Arriel 1 engines. This proposed AD would require performing a high gas generator speed (NG) rating vibration check. We are proposing this AD to prevent an uncommanded in-flight shut-down of the engine, which could result in an emergency landing.

DATES: We must receive comments on this proposed AD by November 13, 2012.

ADDRESSES: You may send comments by any of the following methods:

Federal eRulemaking Portal: Go to http://www.regulations.gov and follow the instructions for sending your comments electronically.

Mail: Docket Management Facility, U.S. Department of Transportation, 1200 New Jersey Avenue SE., West Building Ground Floor, Room W12-140, Washington, DC 20590-0001.

Hand Delivery: Deliver to Mail address above between 9 a.m. and 5 p.m., Monday through Friday, except Federal holidays.

Fax: (202) 493-2251.

Examining the AD Docket

You may examine the AD docket on the Internet at http://www.regulations.gov; or in person at the Docket Operations office between 9 a.m. and 5 p.m., Monday through Friday, except Federal holidays. The AD docket contains this proposed AD, the regulatory evaluation, any comments received, and other information. The street address for the Docket Operations office (phone: (800) 647-5527) is the same as the Mail address provided in the ADDRESSES section. Comments will be available in the AD docket shortly after receipt.

FOR FURTHER INFORMATION CONTACT: Frederick Zink, Aerospace Engineer, Engine Certification Office, FAA, Engine & Propeller Directorate, 12 New England Executive Park, Burlington, MA 01803; email: frederick.zink@faa.gov; phone: 781-238-7779; fax: 781-238-7199.

SUPPLEMENTARY INFORMATION:

Comments Invited

We invite you to send any written relevant data, views, or arguments about this proposed AD. Send your comments to an address listed under the ADDRESSES section. Include ``Docket No. FAA-2012-0901; Directorate Identifier 2012-NE-19-AD'' at the beginning of your comments. We specifically invite comments on the overall regulatory, economic, environmental, and energy aspects of this proposed AD. We will consider all comments received by the closing date and may amend this proposed AD based on those comments.

We will post all comments we receive, without change, to http://www.regulations.gov, including any personal information you provide. We will also post a report summarizing each substantive verbal contact with FAA personnel concerning this proposed AD. Using the search function of the Web site, anyone can find and read the comments in any of our dockets, including, if provided, the name of the individual who sent the comment (or signed the comment on behalf of an association, business, labor union, etc.). You may review the DOT's complete Privacy Act Statement in the Federal Register published on April 11, 2000 (65 FR 19477-78).

Discussion

The European Aviation Safety Agency (EASA), which is the Technical Agent for the Member States of the European Community, has issued EASA Airworthiness Directive 2012-0117, dated July 3, 2012 (referred to after this as ``the MCAI''), to correct an unsafe condition for the specified products. The MCAI states:

Several cases of uncommanded in-flight shut-down (IFSD) have been reported on ARRIEL 1 engines. Results of subsequent investigations showed that some Gas Generator (GG) rear bearing failures have occurred following ``Level 3'' maintenance operations on the GG Assembly. Some of these maintenance operations may have created an unbalanced condition of the GG rotating assembly and, ultimately, failure of the GG rear bearing.

This condition, if not detected and corrected, could lead to an uncommanded engine in-flight shut down and may ultimately lead to an emergency landing.

You may obtain further information by examining the MCAI in the AD docket.

FAA's Determination and Requirements of This Proposed AD

This product has been approved by the aviation authority of France and is approved for operation in the United States. Pursuant to our bilateral agreement with the European Community, EASA has notified us of the unsafe condition described in the MCAI referenced above. We are proposing this AD because we evaluated all information provided by EASA and determined the unsafe condition exists and is likely to exist or develop on other products of the same type design.

Costs of Compliance

Based on the service information, we estimate that this proposed AD would affect about 1,445 products of U.S. registry. We also estimate that it would take about 1 work-hour per product to comply with this proposed AD. The average labor rate is $85 per work-hour. Based on these figures, we estimate the cost of the proposed AD on U.S.

Page 56586

operators to be $122,825. Our cost estimate is exclusive of possible warranty coverage.

Authority for This Rulemaking

Title 49 of the United States Code specifies the FAA's authority to issue rules on aviation safety. Subtitle I, section 106, describes the authority of the FAA Administrator. ``Subtitle VII: Aviation Programs,'' describes in more detail the scope of the Agency's authority.

We are issuing this rulemaking under the authority described in ``Subtitle VII, Part A, Subpart III, Section 44701: General requirements.'' Under that section, Congress charges the FAA with promoting safe flight of civil aircraft in air commerce by prescribing regulations for practices, methods, and procedures the Administrator finds necessary for safety in air commerce. This regulation is within the scope of that authority because it addresses an unsafe condition that is likely to exist or develop on products identified in this rulemaking action.

Regulatory Findings

We determined that this proposed AD would not have federalism implications under Executive Order 13132. This proposed AD would not have a substantial direct effect on the States, on the relationship between the national Government and the States, or on the distribution of power and responsibilities among the various levels of government.

For the reasons discussed above, I certify this proposed regulation:

1. Is not a ``significant regulatory action'' under Executive Order 12866;

2. Is not a ``significant rule'' under the DOT Regulatory Policies and Procedures (44 FR 11034, February 26, 1979); and

3. Will not have a significant economic impact, positive or negative, on a substantial number of small entities under the criteria of the Regulatory Flexibility Act.

   We prepared a regulatory evaluation of the estimated costs to comply with this proposed AD and placed it in the AD docket.

   List of Subjects in 14 CFR Part 39

   Air transportation, Aircraft, Aviation safety, Safety.

   The Proposed Amendment

   Accordingly, under the authority delegated to me by the Administrator, the FAA proposes to amend 14 CFR part 39 as follows:

   PART 39--AIRWORTHINESS DIRECTIVES

1. The authority citation for part 39 continues to read as follows:

   Authority: 49 U.S.C. 106(g), 40113, 44701.

   Sec. 39.13 Amended

2. The FAA amends Sec. 39.13 by adding the following new AD:

   Turbomeca S.A.: Docket No. FAA-2012-0901; Directorate Identifier 2012-NE-19-AD.

   (a) Comments Due Date

   We must receive comments by November 13, 2012.

   (b) Affected Airworthiness Directives (ADs)

   None.

   (c) Applicability

   This AD applies to all Turbomeca S.A. ARRIEL 1A1, 1A2, 1B, 1C, 1C1, 1C2, 1D, 1D1, 1E2, 1K1, 1S, and 1S1 turboshaft engines.

   (d) Reason

   This AD was prompted by several reports of uncommanded in-flight shutdown on Arriel 1 engines. We are issuing this AD to prevent an uncommanded in-flight shutdown of the engine, which could result in an emergency landing.

   (e) Actions and Compliance

   Unless already done, from the effective date of this AD, do the following. After any Level 3 maintenance action on the gas generator (GG) rotating assembly and before returning the engine to service, accomplish a high GG speed (NG) rating vibration check.

   (f) Definition

   Level 3 maintenance on the GG rotating assembly is when the Module 03 is removed from the helicopter for implementation of deep maintenance operation to be performed in accordance with the applicable maintenance instructions.

   (g) Alternative Methods of Compliance (AMOCs)

   The Manager, Engine Certification Office, may approve AMOCs for this AD. Use the procedures found in 14 CFR 39.19 to make your request.

   (h) Related Information

   (1) For more information about this AD, contact Frederick Zink, Aerospace Engineer, Engine Certification Office, FAA, Engine & Propeller Directorate, 12 New England Executive Park, Burlington, MA 01803; email: frederick.zink@faa.gov; phone: 781-238-7779; fax: 781-

   238-7199.

   (2) Refer to Mandatory Continuing Airworthiness Information AD 2012-0117, dated July 3, 2012, for related information.

   Issued in Burlington, Massachusetts, on September 5, 2012.

   Colleen M. D'Alessandro,

   Assistant Manager, Engine & Propeller Directorate, Aircraft Certification Service.

   FR Doc. 2012-22530 Filed 9-12-12; 8:45 am

   BILLING CODE 4910-13-P