Airworthiness Directives; EADS CASA (Type Certificate Previously Held by Construcciones Aeronáuticas, S.A.) Airplanes
Federal Register, Volume 78 Issue 22 (Friday, February 1, 2013)
Federal Register Volume 78, Number 22 (Friday, February 1, 2013)
Rules and Regulations
Pages 7262-7264
From the Federal Register Online via the Government Printing Office www.gpo.gov
FR Doc No: 2013-02074
-----------------------------------------------------------------------
DEPARTMENT OF TRANSPORTATION
Federal Aviation Administration
Docket No. FAA-2012-1102; Directorate Identifier 2012-NM-062-AD; Amendment 39-17333; AD 2013-02-12
RIN 2120-AA64
Airworthiness Directives; EADS CASA (Type Certificate Previously Held by Construcciones Aeronaacuteuticas, S.A.) Airplanes
AGENCY: Federal Aviation Administration (FAA), Department of Transportation (DOT).
Page 7263
ACTION: Final rule.
-----------------------------------------------------------------------
SUMMARY: We are adopting a new airworthiness directive (AD) for all EADS CASA (Type Certificate previously held by Construcciones Aeronaacuteuticas, S.A.) Model CN-235, CN-235-100, CN-235-200, and CN-235-300 airplanes. This AD was prompted by reports of incorrect electrical polarity connections on engine fire extinguishing discharge cartridges. This AD requires a one-time inspection to identify the correct polarity for each pair of electrical connectors on each engine fire extinguisher cartridge, and repair if necessary. We are issuing this AD to detect and correct incorrect polarity connections, which could prevent the actuation of the discharge cartridge in case of automatic fire detection or manual initiation during a potential engine fire, and could result in damage to the airplane and injury to passengers.
DATES: This AD becomes effective March 8, 2013.
The Director of the Federal Register approved the incorporation by reference of a certain publication listed in this AD as of March 8, 2013.
ADDRESSES: You may examine the AD docket on the Internet at http://www.regulations.gov or in person at the U.S. Department of Transportation, Docket Operations, M-30, West Building Ground Floor, Room W12-140, 1200 New Jersey Avenue SE., Washington, DC.
FOR FURTHER INFORMATION CONTACT: Shahram Daneshmandi, Aerospace Engineer, International Branch, ANM-116, Transport Airplane Directorate, FAA, 1601 Lind Avenue SW., Renton, WA 98057-3356; telephone (425) 227-1112; fax (425) 227-1149.
SUPPLEMENTARY INFORMATION:
Discussion
We issued a notice of proposed rulemaking (NPRM) to amend 14 CFR part 39 to include an AD that would apply to the specified products. That NPRM was published in the Federal Register on October 18, 2012 (77 FR 64053). That NPRM proposed to correct an unsafe condition for the specified products. The Mandatory Continuing Airworthiness Information (MCAI) states:
Reports have been received of finding wrong electrical polarity connections of engine fire extinguishing discharge cartridges on CASA CN-235 aeroplanes. The results of the subsequent investigation showed that the incorrect discharge cartridge assembly was caused by production line errors.
This condition, if not detected and corrected, could prevent the actuation of the discharge cartridge in case of automatic fire detection or manual initiation in case of engine fire, possibly resulting in damage to the aeroplane and injury to occupants.
To address this potential unsafe condition, EADS CASA (Airbus Military) developed instructions to identify erroneous wiring polarity installation.
For the reasons described above this European Aviation Safety Agency AD requires a one-time inspection to verify proper electrical polarity of wiring of each engine fire extinguisher discharge cartridge and, depending on findings, corrective action accomplish the repair.
You may obtain further information by examining the MCAI in the AD docket.
Comments
We gave the public the opportunity to participate in developing this AD. We received no comments on the NPRM (77 FR 64053, October 18, 2012) or on the determination of the cost to the public.
Conclusion
We reviewed the available data and determined that air safety and the public interest require adopting the AD as proposed.
Costs of Compliance
We estimate that this AD will affect 6 products of U.S. registry. We also estimate that it will take about 4 work-hours per product to comply with the basic requirements of this AD. The average labor rate is $85 per work-hour. Based on these figures, we estimate the cost of this AD to the U.S. operators to be $2,040, or $340 per product.
We have received no definitive data that would enable us to provide cost estimates for the on-condition actions specified in this AD.
Authority for This Rulemaking
Title 49 of the United States Code specifies the FAA's authority to issue rules on aviation safety. Subtitle I, section 106, describes the authority of the FAA Administrator. ``Subtitle VII: Aviation Programs,'' describes in more detail the scope of the Agency's authority.
We are issuing this rulemaking under the authority described in ``Subtitle VII, Part A, Subpart III, Section 44701: General requirements.'' Under that section, Congress charges the FAA with promoting safe flight of civil aircraft in air commerce by prescribing regulations for practices, methods, and procedures the Administrator finds necessary for safety in air commerce. This regulation is within the scope of that authority because it addresses an unsafe condition that is likely to exist or develop on products identified in this rulemaking action.
Regulatory Findings
We determined that this AD will not have federalism implications under Executive Order 13132. This AD will not have a substantial direct effect on the States, on the relationship between the national government and the States, or on the distribution of power and responsibilities among the various levels of government.
For the reasons discussed above, I certify that this AD:
1. Is not a ``significant regulatory action'' under Executive Order 12866;
2. Is not a ``significant rule'' under the DOT Regulatory Policies and Procedures (44 FR 11034, February 26, 1979);
3. Will not affect intrastate aviation in Alaska; and
4. Will not have a significant economic impact, positive or negative, on a substantial number of small entities under the criteria of the Regulatory Flexibility Act.
We prepared a regulatory evaluation of the estimated costs to comply with this AD and placed it in the AD docket.
Examining the AD Docket
You may examine the AD docket on the Internet at http://www.regulations.gov; or in person at the Docket Operations office between 9 a.m. and 5 p.m., Monday through Friday, except Federal holidays. The AD docket contains the NPRM (77 FR 64053, October 18, 2012), the regulatory evaluation, any comments received, and other information. The street address for the Docket Operations office (telephone (800) 647-5527) is in the ADDRESSES section. Comments will be available in the AD docket shortly after receipt.
List of Subjects in 14 CFR Part 39
Air transportation, Aircraft, Aviation safety, Incorporation by reference, Safety.
Adoption of the Amendment
Accordingly, under the authority delegated to me by the Administrator, the FAA amends 14 CFR part 39 as follows:
PART 39--AIRWORTHINESS DIRECTIVES
0
1. The authority citation for part 39 continues to read as follows:
Authority: 49 U.S.C. 106(g), 40113, 44701.
Sec. 39.13 Amended
0
2. The FAA amends Sec. 39.13 by adding the following new AD:
2013-02-12 EADS CASA (Type Certificate previously held by Construcciones Aeronaacuteuticas, S.A.): Amendment 39-
Page 7264
17333. Docket No. FAA-2012-1102; Directorate Identifier 2012-NM-062-
AD.
(a) Effective Date
This airworthiness directive (AD) becomes effective March 8, 2013.
(b) Affected ADs
None.
(c) Applicability
This AD applies to all EADS CASA (Type Certificate previously held by Construcciones Aeronaacuteuticas, S.A.) Model CN-235, CN-
235-100, CN-235-200, and CN-235-300 airplanes, certificated in any category, all serial numbers.
(d) Subject
Air Transport Association (ATA) of America Code 26, Fire protection.
(e) Reason
This AD was prompted by reports of incorrect electrical polarity connections on engine fire extinguishing discharge cartridges. We are issuing this AD to detect and correct incorrect polarity connections, which could prevent the actuation of the discharge cartridge in case of automatic fire detection or manual initiation during a potential engine fire, and could result in damage to the airplane and injury to passengers.
(f) Compliance
You are responsible for having the actions required by this AD performed within the compliance times specified, unless the actions have already been done.
(g) Inspection
Within 30 days after the effective date of this AD, do a one-
time inspection to identify the correct polarity for each pair of electrical connectors on each engine fire extinguisher cartridge, in accordance with the Instructions of Airbus Military All Operator Letter 235-020, dated March 9, 2012.
(h) Corrective Action
If, during the inspection required by paragraph (g) of this AD, erroneous wiring polarity is detected: Before further flight, repair in accordance with a method approved by the Manager, International Branch, ANM-116, Transport Airplane Directorate, FAA; or European Aviation Safety Agency (EASA) (or its delegated agent).
(i) Other FAA AD Provisions
The following provisions also apply to this AD:
(1) Alternative Methods of Compliance (AMOCs): The Manager, International Branch, ANM-116, Transport Airplane Directorate, FAA, has the authority to approve AMOCs for this AD, if requested using the procedures found in 14 CFR 39.19. In accordance with 14 CFR 39.19, send your request to your principal inspector or local Flight Standards District Office, as appropriate. If sending information directly to the International Branch, send it to ATTN: Shahram Daneshmandi, Aerospace Engineer, International Branch, ANM-116, Transport Airplane Directorate, FAA, 1601 Lind Avenue SW., Renton, WA 98057-3356; telephone (425) 227-1112; fax (425) 227-1149. Information may be emailed to: 9-ANM-116-AMOC-REQUESTS@faa.gov. Before using any approved AMOC, notify your appropriate principal inspector, or lacking a principal inspector, the manager of the local flight standards district office/certificate holding district office. The AMOC approval letter must specifically reference this AD.
(2) Airworthy Product: For any requirement in this AD to obtain corrective actions from a manufacturer or other source, use these actions if they are FAA-approved. Corrective actions are considered FAA-approved if they are approved by the State of Design Authority (or their delegated agent). You are required to assure the product is airworthy before it is returned to service.
(j) Related Information
Refer to MCAI EASA Airworthiness Directive 2012-0045, dated March 21, 2012, and Airbus Military All Operator Letter 235-020, dated March 9, 2012, for related information.
(k) Material Incorporated by Reference
(1) The Director of the Federal Register approved the incorporation by reference (IBR) of the service information listed in this paragraph under 5 U.S.C. 552(a) and 1 CFR part 51.
(2) You must use this service information as applicable to do the actions required by this AD, unless the AD specifies otherwise.
(i) Airbus Military All Operator Letter 235-020, dated March 9, 2012.
(ii) Reserved.
(3) For service information identified in this AD, contact EADS-
CASA, Military Transport Aircraft Division (MTAD), Integrated Customer Services (ICS), Technical Services, Avenida de Aragoacuten 404, 28022 Madrid, Spain; telephone +34 91 585 55 84; fax +34 91 585 55 05; email MTA.TechnicalService@casa.eads.net; Internet http://www.eads.net.
(4) You may review copies of the service information at the FAA, Transport Airplane Directorate, 1601 Lind Avenue SW., Renton, WA. For information on the availability of this material at the FAA, call 425-227-1221.
(5) You may view this service information that is incorporated by reference at the National Archives and Records Administration (NARA). For information on the availability of this material at NARA, call 202-741-6030, or go to: http://www.archives.gov/federal-register/cfr/ibr-locations.html.
Issued in Renton, Washington, on January 23, 2013.
Ali Bahrami,
Manager, Transport Airplane Directorate, Aircraft Certification Service.
FR Doc. 2013-02074 Filed 1-31-13; 8:45 am
BILLING CODE 4910-13-P
