Airworthiness Directives: Gulfstream Aerospace LP Model Galaxy and Gulfstream 200 Airplanes
Federal Register: June 25, 2010 (Volume 75, Number 122)
Proposed Rules
Page 36296-36298
From the Federal Register Online via GPO Access [wais.access.gpo.gov]
DOCID:fr25jn10-9
Proposed Rules
Federal Register
This section of the FEDERAL REGISTER contains notices to the public of the proposed issuance of rules and regulations. The purpose of these notices is to give interested persons an opportunity to participate in the rule making prior to the adoption of the final rules.
Page 36296
DEPARTMENT OF TRANSPORTATION
Federal Aviation Administration 14 CFR Part 39
Docket No. FAA-2010-0555; Directorate Identifier 2010-NM-053-AD
RIN 2120-AA64
Airworthiness Directives; Gulfstream Aerospace LP (Type
Certificate Previously Held by Israel Aircraft Industries, Ltd.) Model
Galaxy and Gulfstream 200 Airplanes
AGENCY: Federal Aviation Administration (FAA), DOT.
ACTION: Notice of proposed rulemaking (NPRM).
SUMMARY: We propose to adopt a new airworthiness directive (AD) for the products listed above. This proposed AD results from mandatory continuing airworthiness information (MCAI) originated by an aviation authority of another country to identify and correct an unsafe condition on an aviation product. The MCAI describes the unsafe condition as: Extension of airbrakes above 360 KIAS [knots indicated air speed]/0.79 Mi[Mach indicated] results in aerodynamic driven vibration of the airbrake which, if not limited per Revision 14 to the AFM [airplane flight manual], can lead to high cycle fatigue failure of the airbrake in board hinge. The unsafe condition is high cycle fatigue of the airbrake in-board hinge, which can result in loss of the airbrake, which in turn can lead to reduced controllability of the airplane. The proposed AD would require actions that are intended to address the unsafe condition described in the MCAI.
DATES: We must receive comments on this proposed AD by August 9, 2010.
ADDRESSES: You may send comments by any of the following methods:
Federal eRulemaking Portal: Go to http:// www.regulations.gov. Follow the instructions for submitting comments.
Fax: (202) 493-2251.
Mail: U.S. Department of Transportation, Docket
Operations, M-30, West Building Ground Floor, Room W12-140, 1200 New
Jersey Avenue, SE., Washington, DC 20590.
Hand Delivery: U.S. Department of Transportation, Docket
Operations, M-30, West Building Ground Floor, Room W12-40, 1200 New
Jersey Avenue, SE., Washington, DC, between 9 a.m. and 5 p.m., Monday through Friday, except Federal holidays.
For service information identified in this proposed AD, contact
Gulfstream Aerospace Corporation, P.O. Box 2206, Mail Station D-25,
Savannah, Georgia 31402-2206; telephone 800-810-4853; fax 912-965-3520; e-mail pubs@gulfstream.com; Internet http://www.gulfstream.com/ product_support/technical_pubs/pubs/index.htm. You may review copies of the referenced service information at the FAA, Transport Airplane
Directorate, 1601 Lind Avenue, SW., Renton, Washington. For information on the availability of this material at the FAA, call 425-227-1221.
Examining the AD Docket
You may examine the AD docket on the Internet at http:// www.regulations.gov; or in person at the Docket Operations office between 9 a.m. and 5 p.m., Monday through Friday, except Federal holidays. The AD docket contains this proposed AD, the regulatory evaluation, any comments received, and other information. The street address for the Docket Operations office (telephone (800) 647-5527) is in the ADDRESSES section. Comments will be available in the AD docket shortly after receipt.
FOR FURTHER INFORMATION CONTACT: Mike Borfitz, Aerospace Engineer,
International Branch, ANM-116, Transport Airplane Directorate, FAA, 1601 Lind Avenue, SW., Renton, Washington 98057-3356; telephone (425) 227-2677; fax (425) 227-1149.
SUPPLEMENTARY INFORMATION:
Comments Invited
We invite you to send any written relevant data, views, or arguments about this proposed AD. Send your comments to an address listed under the ADDRESSES section. Include ``Docket No. FAA-2010-0555;
Directorate Identifier 2010-NM-053-AD, at the beginning of your comments. We specifically invite comments on the overall regulatory, economic, environmental, and energy aspects of this proposed AD. We will consider all comments received by the closing date and may amend this proposed AD based on those comments.
We have lengthened the 30-day comment period for proposed ADs that address MCAI originated by aviation authorities of other countries to provide adequate time for interested parties to submit comments. The comment period for these proposed ADs is now typically 45 days, which is consistent with the comment period for domestic transport ADs.
We will post all comments we receive, without change, to http:// www.regulations.gov, including any personal information you provide. We will also post a report summarizing each substantive verbal contact we receive about this proposed AD.
Discussion
The Civil Aviation Authority of Israel (CAAI), which is the aviation authority for Israel, has issued Israeli Airworthiness
Directive 01-10-01-07R1, dated January 20, 2010 (referred to after this as ``the MCAI''), to correct an unsafe condition for the specified products. The MCAI states:
Extension of airbrakes above 360 KIAS [knots indicated air speed]/0.79 Mi[Mach indicated] results in aerodynamic driven vibration of the airbrake which, if not limited per Revision 14 to the AFM [airplane flight manual], can lead to high cycle fatigue failure of the airbrake in board hinge.
The unsafe condition is high cycle fatigue of the airbrake in-board hinge, which can result in loss of the airbrake, which in turn can lead to reduced controllability of the airplane. The required action includes revising the Limitations section of the Gulfstream 200
Airplane Flight Manual to prohibit deploying the air brakes above the stated speed. You may obtain further information by examining the MCAI in the AD docket.
FAA's Determination and Requirements of This Proposed AD
This product has been approved by the aviation authority of another country, and is approved for operation in the United States. Pursuant to our bilateral agreement with the State of Design Authority, we have been notified of the unsafe condition described in the MCAI and service information
Page 36297
referenced above. We are proposing this AD because we evaluated all pertinent information and determined an unsafe condition exists and is likely to exist or develop on other products of the same type design.
Differences Between This AD and the MCAI or Service Information
We have reviewed the MCAI and related service information and, in general, agree with their substance. But we might have found it necessary to use different words from those in the MCAI to ensure the
AD is clear for U.S. operators and is enforceable. In making these changes, we do not intend to differ substantively from the information provided in the MCAI and related service information.
We might also have proposed different actions in this AD from those in the MCAI in order to follow FAA policies. Any such differences are highlighted in a Note within the proposed AD.
Costs of Compliance
Based on the service information, we estimate that this proposed AD would affect about 90 products of U.S. registry. We also estimate that it would take about 1 work-hour per product to comply with the basic requirements of this proposed AD. The average labor rate is $85 per work-hour. Based on these figures, we estimate the cost of the proposed
AD on U.S. operators to be $7,650, or $85 per product.
Authority for This Rulemaking
Title 49 of the United States Code specifies the FAA's authority to issue rules on aviation safety. Subtitle I, section 106, describes the authority of the FAA Administrator. ``Subtitle VII: Aviation
Programs,'' describes in more detail the scope of the Agency's authority.
We are issuing this rulemaking under the authority described in
``Subtitle VII, Part A, Subpart III, Section 44701: General requirements.'' Under that section, Congress charges the FAA with promoting safe flight of civil aircraft in air commerce by prescribing regulations for practices, methods, and procedures the Administrator finds necessary for safety in air commerce. This regulation is within the scope of that authority because it addresses an unsafe condition that is likely to exist or develop on products identified in this rulemaking action.
Regulatory Findings
We determined that this proposed AD would not have federalism implications under Executive Order 13132. This proposed AD would not have a substantial direct effect on the States, on the relationship between the national Government and the States, or on the distribution of power and responsibilities among the various levels of government.
For the reasons discussed above, I certify this proposed regulation: 1. Is not a ``significant regulatory action'' under Executive Order 12866; 2. Is not a ``significant rule'' under the DOT Regulatory Policies and Procedures (44 FR 11034, February 26, 1979); and 3. Will not have a significant economic impact, positive or negative, on a substantial number of small entities under the criteria of the Regulatory Flexibility Act.
We prepared a regulatory evaluation of the estimated costs to comply with this proposed AD and placed it in the AD docket.
List of Subjects in 14 CFR Part 39
Air transportation, Aircraft, Aviation safety, Safety.
The Proposed Amendment
Accordingly, under the authority delegated to me by the
Administrator, the FAA proposes to amend 14 CFR part 39 as follows:
PART 39--AIRWORTHINESS DIRECTIVES 1. The authority citation for part 39 continues to read as follows:
Authority: 49 U.S.C. 106(g), 40113, 44701.
Sec. 39.13 [Amended] 2. The FAA amends Sec. 39.13 by adding the following new AD:
Gulfstream Aerospace LP (Type Certificate Previously Held by Israel
Aircraft Industries, Ltd.): Docket No. FAA-2010-0555; Directorate
Identifier 2010-NM-053-AD.
Comments Due Date
(a) We must receive comments by August 9, 2010.
Affected ADs
(b) None.
Applicability
(c) This AD applies to Gulfstream Aerospace LP (Type Certificate previously held by Israel Aircraft Industries, Ltd.) Model Galaxy and Gulfstream 200 airplanes, all serial numbers, certificated in any category.
Subject
(d) Air Transport Association (ATA) of America Code 27: Flight controls.
Reason
(e) The mandatory continuing airworthiness information (MCAI) states:
Extension of airbrakes above 360 KIAS [knots indicated air speed]/0.79 Mi[Mach indicated] results in aerodynamic driven vibration of the airbrake which, if not limited per Revision 14 to the AFM [airplane flight manual], can lead to high cycle fatigue failure of the airbrake in board hinge.
The unsafe condition is high cycle fatigue of the airbrake in-board hinge, which can result in loss of the airbrake, which in turn can lead to reduced controllability of the airplane.
Compliance
(f) You are responsible for having the actions required by this
AD performed within the compliance times specified, unless the actions have already been done.
Actions
(g) Within 60 days after the effective date of this AD: Revise the Limitations section of the Gulfstream 200 Airplane Flight Manual
(AFM) to include the following statement. This may be done by inserting a copy of this AD into the AFM.
``MAXIMUM AIR BRAKES OPERATION/EXTENDED SPEED 360 KIAS/0.79 Mi
NOTE
During emergency, air brakes may be used at speeds above 0.79
Mi.''
Note 1: When a statement identical to that in paragraph (g) of this AD has been included in the general revisions of the AFM, the general revisions may be inserted into the AFM, and the copy of this
AD may be removed from the AFM.
Note 2: The Gulfstream 200 AFM applies to both the Model Galaxy and Gulfstream 200 airplanes.
FAA AD Differences
Note 3: This AD differs from the MCAI and/or service information as follows: No differences.
Other FAA AD Provisions
(h) The following provisions also apply to this AD:
(1) Alternative Methods of Compliance (AMOCs): The Manager,
International Branch, ANM-116, Transport Airplane Directorate, FAA, has the authority to approve AMOCs for this AD, if requested using the procedures found in 14 CFR 39.19. Send information to ATTN: Mike
Borfitz, Aerospace Engineer, International Branch, ANM-116,
Transport Airplane Directorate, FAA, 1601 Lind Avenue, SW., Renton,
Washington 98057-3356; telephone (425) 227-2677; fax (425) 227-1149.
Before using any approved AMOC on any airplane to which the AMOC applies, notify your principal maintenance inspector (PMI) or principal avionics inspector (PAI), as appropriate, or lacking a principal inspector, your local Flight Standards District Office.
The AMOC approval letter must specifically reference this AD.
(2) Airworthy Product: For any requirement in this AD to obtain corrective actions from a manufacturer or other source, use these actions if they are FAA-approved. Corrective actions are considered
FAA-approved if they are approved by the State of Design Authority
Page 36298
(or their delegated agent). You are required to assure the product is airworthy before it is returned to service.
(3) Reporting Requirements: For any reporting requirement in this AD, under the provisions of the Paperwork Reduction Act (44
U.S.C. 3501 et seq.), the Office of Management and Budget (OMB) has approved the information collection requirements and has assigned
OMB Control Number 2120-0056.
Related Information
(i) Refer to MCAI Israeli Airworthiness Directive 01-10-01-07R1, dated January 20, 2010, for related information.
Issued in Renton, Washington, on June 21, 2010.
Ali Bahrami,
Manager, Transport Airplane Directorate, Aircraft Certification
Service.
FR Doc. 2010-15402 Filed 6-24-10; 8:45 am
BILLING CODE 4910-13-P
