Special Conditions:
Federal Register: February 14, 2011 (Volume 76, Number 30)
Proposed Rules
Page 8314-8315
From the Federal Register Online via GPO Access [wais.access.gpo.gov]
DOCID:fr14fe11-15
DEPARTMENT OF TRANSPORTATION
Federal Aviation Administration 14 CFR Part 25
Docket No. NM444 Special Conditions No. 25-11-03-SC
Special Conditions: Gulfstream Model GVI Airplane; Operation
Without Normal Electric Power
AGENCY: Federal Aviation Administration (FAA), DOT.
ACTION: Notice of proposed special conditions.
SUMMARY: This action proposes special conditions for the Gulfstream GVI airplane. The Gulfstream GVI airplane will have numerous electrically operated systems whose function is needed for continued safe flight and landing of the airplane. The applicable airworthiness regulations do not contain adequate or appropriate safety standards for these design features. These proposed special conditions contain the additional safety standards that the Administrator considers necessary to establish a level of safety equivalent to that established by the existing airworthiness standards.
DATES: We must receive your comments by March 31, 2011.
ADDRESSES: You must mail two copies of your comments to: Federal
Aviation Administration, Transport Airplane Directorate, Attn: Rules
Docket (ANM-113), Docket No. NM444, 1601 Lind Avenue, SW., Renton,
Washington 98057-3356. You may deliver two copies to the Transport
Airplane Directorate at the above address. You must mark your comments:
Docket No. NM444. You can inspect comments in the Rules Docket weekdays, except Federal holidays, between 7:30 a.m. and 4 p.m.
FOR FURTHER INFORMATION CONTACT: Nazih Khaouly, FAA, Airplane and
Flight Crew Interface Branch, ANM-111, Transport Standards Staff,
Transport Airplane Directorate, Aircraft Certification Service, 1601
Lind Avenue, SW., Renton, Washington 98057-3356; telephone (425) 227- 2432; facsimile (425) 227-1320.
SUPPLEMENTARY INFORMATION:
Comments Invited
We invite interested people to take part in this rulemaking by sending written comments, data, or views. The most helpful comments reference a specific portion of the special conditions, explain the reason for any recommended change, and include supporting data. We ask that you send us two copies of written comments.
We will file in the docket all comments we receive, as well as a report summarizing each substantive public contact with FAA personnel concerning these special conditions. You can inspect the docket before and after the comment closing date. If you wish to review the docket in person, go to the address in the ADDRESSES section of this preamble between 7:30 a.m. and 4 p.m., Monday through Friday, except Federal holidays.
We will consider all comments we receive on or before the closing date for comments. We will consider comments filed late if it is possible to do so without incurring expense or delay. We may change these special conditions based on the comments we receive.
If you want us to acknowledge receipt of your comments on this proposal, include with your comments a self-addressed, stamped postcard on which you have written the docket number. We will stamp the date on the postcard and mail it back to you.
Background
On March 29, 2005, Gulfstream Aerospace Corporation (hereafter referred to as ``Gulfstream'') applied for an FAA type certificate for its new Gulfstream Model GVI passenger airplane. Gulfstream later applied for, and was granted, an extension of time for the type certificate, which changed the effective application date to September 28, 2006. The Gulfstream Model GVI airplane will be an all-new, two- engine jet transport airplane with an executive cabin interior. The maximum takeoff weight will be 99,600 pounds, with a maximum passenger count of 19 passengers.
Page 8315
Type Certification Basis
Under provisions of Title 14 Code of Federal Regulations (14 CFR) 21.17, Gulfstream must show that the Gulfstream Model GVI airplane
(hereafter referred to as ``the GVI'') meets the applicable provisions of 14 CFR part 25, as amended by Amendments 25-1 through 25-119, 25- 122, and 25-124. If the Administrator finds that the applicable airworthiness regulations (i.e., 14 CFR part 25) do not contain adequate or appropriate safety standards for the GVI because of a novel or unusual design feature, special conditions are prescribed under the provisions of Sec. 21.16.
In addition to complying with the applicable airworthiness regulations and special conditions, the GVI must comply with the fuel vent and exhaust emission requirements of 14 CFR part 34 and the noise certification requirements of 14 CFR part 36. The FAA must also issue a finding of regulatory adequacy pursuant to section 611 of Public Law 92-574, the ``Noise Control Act of 1972.''
The FAA issues special conditions, as defined in 14 CFR 11.19, in accordance with Sec. 11.38, and they become part of the type certification basis under Sec. 21.17(a)(2).
Special conditions are initially applicable to the model for which they are issued. Should the type certificate for that model be amended later to include any other model that incorporates the same novel or unusual design features, the special conditions would also apply to the other model under provisions of Sec. 21.101.
Novel or Unusual Design Features
The GVI incorporates an electronic flight control system that requires a continuous source of electrical power in order to keep the system operable. Due to rapid improvements in airplane technology, the applicable airworthiness regulations do not contain adequate or appropriate safety standards for these design features. These proposed special conditions for the GVI contain the additional safety standards that the Administrator considers necessary to establish a level of safety equivalent to that established by the existing airworthiness standards.
Discussion of Proposed Special Conditions
The GVI incorporates an electronic flight control system that requires a continuous source of electrical power in order to keep the system operable. The criticality of this system is such that their failure will either reduce the capability of the airplane or the ability of the crew to cope with adverse operating conditions, or prevent continued safe flight and landing of the airplane. The airworthiness standards of part 25 do not contain adequate or appropriate standards for protection of these systems from the adverse effects of operation without normal electrical power.
The current rule, Sec. 25.1351(d), Amendment 25-72, requires safe operation under visual flight rules (VFR) conditions for at least five minutes after loss of all normal electrical power. This rule was structured around traditional airplane designs that used mechanical control cables and linkages for flight control. These manual controls allowed the crew to maintain aerodynamic control of the airplane for an indefinite period of time after loss of all electrical power. Under these conditions, the mechanical flight control system provided the crew with the ability to fly the airplane while attempting to identify the cause of the electrical failure, start the engine(s) if necessary, and reestablish some of the electrical power generation capability, if possible.
To maintain the same level of safety associated with traditional designs, the GVI must be designed for operation with the normal sources of engine and auxiliary power unit (APU) generated electrical power inoperative. Service experience has shown that loss of all electrical power from the airplane's engine and APU driven generators is not extremely improbable. Thus, Gulfstream must demonstrate that the airplane is capable of recovering adequate primary electrical power generation for safe flight and landing.
For compliance purposes, a test demonstration of the loss of normal engine generator must be established such that: 1. The failure condition should be assumed to occur during night instrument meteorological conditions (IMC) at the most critical phase of the flight relative to the electrical power system design and distribution of equipment loads on the system. 2. After the unrestorable loss of normal engine generator power, the airplane engine restart capability must be provided and operations continued in IMC. 3. The airplane should be demonstrated to be capable of continuous safe flight and landing. The length of time must be computed based on the maximum diversion time capability for which the airplane is being certified. Consideration for speed reductions resulting from the associated failure must be made. 4. Availability of APU operation should not be considered in establishing emergency power system adequacy.
Applicability
As discussed above, these proposed special conditions are applicable to the GVI. Should Gulfstream apply at a later date for a change to the type certificate to include another model incorporating the same novel or unusual design features, these proposed special conditions would apply to that model as well.
Conclusion
This action affects only certain novel or unusual design features of the GVI. It is not a rule of general applicability.
List of Subjects in 14 CFR Part 25
Aircraft, Aviation safety, Reporting and recordkeeping requirements.
The authority citation for these special conditions is as follows:
Authority: 49 U.S.C. 106(g), 40113, 44701, 44702, 44704.
The Proposed Special Conditions
Accordingly, the Federal Aviation Administration (FAA) proposes the following special conditions as part of the type certification basis for the GVI airplanes.
Since the total loss of normal generated electrical power in two engine aircraft has not achieved the extremely improbable level, and since the loss of all electrical power may be catastrophic to aircraft utilizing an electronic flight control system, the following special conditions are proposed in lieu of 14 CFR 25.1351(d):
It must be demonstrated by test or a combination of test and analysis that the airplane can continue safe flight and landing with inoperative normal engine and APU generator electrical power
(electrical power sources excluding the battery and any other standby electrical sources). The airplane operation should be considered at the critical phase of flight and include the ability to restart the engines and maintain flight for the maximum diversion time capability being certified.
Issued in Renton, Washington, on February 3, 2011.
Jeffrey E. Duven,
Acting Manager,Transport Airplane Directorate,Aircraft Certification
Service.
FR Doc. 2011-3210 Filed 2-11-11; 8:45 am
BILLING CODE 4910-13-P
