Special Conditions:

Federal Register Volume 76, Number 121 (Thursday, June 23, 2011)

Rules and Regulations

Pages 36870-36871

From the Federal Register Online via the Government Printing Office [www.gpo.gov]

FR Doc No: 2011-15708

Page 36870

DEPARTMENT OF TRANSPORTATION

Federal Aviation Administration 14 CFR Part 25

Docket No. NM441; Special Conditions No. 25-433-SC

Special Conditions: Gulfstream Model GVI Airplane; Design Roll

Maneuver Requirement for Electronic Flight Controls

AGENCY: Federal Aviation Administration (FAA), DOT.

ACTION: Final special conditions.

SUMMARY: These special conditions are issued for the Gulfstream GVI airplane. This airplane will have a novel or unusual design feature associated with an electronic flight control system that provides roll control of the airplane through pilot inputs to the flight computers.

These special conditions contain the additional safety standards that the Administrator considers necessary to establish a level of safety equivalent to that established by the existing airworthiness standards.

DATES: Effective Date: July 25, 2011.

FOR FURTHER INFORMATION CONTACT: Carl Niedermeyer, FAA, Airframe/Cabin

Safety Branch, ANM-115, Transport Standards Staff, Transport Airplane

Directorate, Aircraft Certification Service, 1601 Lind Avenue, SW.,

Renton, Washington 98057-3356; telephone (425) 227-2279; electronic mail carl.niedermeyer@faa.gov.

SUPPLEMENTARY INFORMATION:

Background

On March 29, 2005, Gulfstream Aerospace Corporation (hereafter referred to as ``Gulfstream'') applied for an FAA type certificate for its new Gulfstream Model GVI passenger airplane. Gulfstream later applied for, and was granted, an extension of time for the type certificate, which changed the effective application date to September 28, 2006. The Gulfstream Model GVI airplane will be an all-new, two- engine jet transport airplane. The maximum takeoff weight will be 99,600 pounds, with a maximum passenger count of 19 passengers.

Type Certification Basis

Under provisions of Title 14, Code of Federal Regulations (14 CFR) 21.17, Gulfstream must show that the Gulfstream Model GVI airplane

(hereafter referred to as ``the GVI'') meets the applicable provisions of 14 CFR part 25, as amended by Amendments 25-1 through 25-119, 25- 122, and 25-124. If the Administrator finds that the applicable airworthiness regulations (i.e., 14 CFR part 25) do not contain adequate or appropriate safety standards for the GVI because of a novel or unusual design feature, special conditions are prescribed under the provisions of Sec. 21.16.

In addition to complying with the applicable airworthiness regulations and special conditions, the GVI must comply with the fuel vent and exhaust emission requirements of 14 CFR part 34 and the noise certification requirements of 14 CFR part 36. The FAA must also issue a finding of regulatory adequacy pursuant to section 611 of Public Law 92-574, the ``Noise Control Act of 1972.''

The FAA issues special conditions, as defined in 14 CFR 11.19, in accordance with Sec. 11.38, and they become part of the type certification basis under Sec. 21.17(a)(2).

Special conditions are initially applicable to the model for which they are issued. Should the type certificate for that model be amended later to include any other model that incorporates the same novel or unusual design features, the special conditions would also apply to the other model under provisions of Sec. 21.101.

Novel or Unusual Design Features

The Gulfstream Model GVI airplane is equipped with an electronic flight control system that provides roll control of the airplane through pilot inputs to the flight computers. The current design roll maneuver requirement for structural loads in 14 CFR part 25 is inadequate for addressing an airplane with electronic flight controls that affect maneuvering. Special conditions are needed to take into account the effects of an electronic flight control system.

Discussion

The GVI is equipped with an electronic flight control system that provides roll control of the airplane through pilot inputs to the flight computers. Current part 25 airworthiness regulations account for

``control laws'' for which aileron deflection is proportional to control wheel deflection. They do not address any nonlinearities \1\ or other effects on aileron and spoiler actuation that may be caused by electronic flight controls. Therefore, the FAA considers the flight control system to be a novel and unusual feature compared to those envisioned when the current regulations were adopted. Since this type of system may affect flight loads, and therefore the structural capability of the airplane, special conditions are needed to address these effects.

\1\ A nonlinearity is a situation where output does not change in the same proportion as input.

These special conditions differ from current requirements in that the special conditions require that the roll maneuver result from defined movements of the cockpit roll control as opposed to defined aileron deflections. Also, these special conditions require an additional load condition at design maneuvering speed (VA), in which the cockpit roll control is returned to neutral following the initial roll input.

Discussion of Comments

Notice of proposed special conditions No. 25-11-01-SC for

Gulfstream GVI airplanes was published in the Federal Register on

February 14, 2011 (76 FR 8319). Only one comment was received, which was supportive, so these special conditions are adopted as proposed.

Applicability

As discussed above, these special conditions are applicable to the

Gulfstream Model GVI airplane. Should Gulfstream apply at a later date for a change to the type certificate to include another model incorporating the same novel or unusual design features, these special conditions would apply to that model as well.

Conclusion

This action affects only certain novel or unusual design features of the GVI. It is not a rule of general applicability.

List of Subjects in 14 CFR Part 25

Aircraft, Aviation safety, Reporting and recordkeeping requirements.

The authority citation for these special conditions is as follows:

Authority: 49 U.S.C. 106(g), 40113, 44701, 44702, 44704.

The Special Conditions

Accordingly, pursuant to the authority delegated to me by the

Administrator, the following special conditions are issued as part of the type certification basis for Gulfstream GVI airplanes.

In lieu of compliance with Sec. 25.349(a), Gulfstream must comply with the following special conditions.

The following conditions, speeds, and cockpit roll control motions

(except as the motions may be limited by pilot effort) must be considered in combination with an airplane load factor of zero and of two-thirds of the positive maneuvering factor used in design. In determining the resulting control surface deflections, the torsional flexibility of the wing must be

Page 36871

considered in accordance with Sec. 25.301(b): 1. Conditions corresponding to steady rolling velocities must be investigated. In addition, conditions corresponding to maximum angular acceleration must be investigated for airplanes with engines or other weight concentrations outboard of the fuselage. For the angular acceleration conditions, zero rolling velocity may be assumed in the absence of a rational time history investigation of the maneuver. 2. At VA, sudden movement of the cockpit roll control up to the limit is assumed. The position of the cockpit roll control must be maintained until a steady roll rate is achieved and then must be returned suddenly to the neutral position. 3. At VC, the cockpit roll control must be moved suddenly and maintained so as to achieve a roll rate not less than that obtained in paragraph 2. 4. At VD, the cockpit roll control must be moved suddenly and maintained so as to achieve a roll rate not less than one third of that obtained in paragraph 2.

Issued in Renton, Washington, on June 13, 2011.

Ali Bahrami,

Manager, Transport Airplane Directorate, Aircraft Certification

Service.

FR Doc. 2011-15708 Filed 6-22-11; 8:45 am

BILLING CODE 4910-13-P